航空发动机双转子系统高/低压涡轮碰摩振动分析

摘要
图/表
参考文献(20)
相关文章 (9)

全文: PDF (6412 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要针对航空发动机碰摩问题，考虑高压涡轮与低压涡轮碰摩，建立了五点支承的航空发动机双转子系统动力学模型。碰摩力模型采用Lankarani-Nikravesh滞回力模型。利用龙格-库塔法进行数值计算，并研究了双转子系统的频谱特性、幅频特性。最后，基于双转子实验台，部分验证了数值计算结果。结果表明：（1）双转子系统碰摩会使系统产生激励频率以及组合频率，并发生组合共振；（2）高压涡轮碰摩会导致系统产生反向涡动全周碰摩，低压涡轮碰摩对高压涡轮碰摩有抑制作用，即高低压涡轮同时碰摩时与高压涡轮碰摩时相比，系统发生反向涡动的转速区间更窄、振动幅值更低；（3）在升降速过程中，碰摩会导致双转子系统出现单个甚至多个双稳态现象。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	聂日敏1
	2
	3
	曹树谦1
	2
	3
	郭虎伦1
	2
	3

关键词 ：高/低压涡轮碰摩, 双转子系统, 组合共振, 反向涡动, 双稳态现象

Abstract：Considering rub-impact of high pressure (HP) and low pressure (LP) turbines of an aeroengine, a five-point supported aeroengine dual-rotor system’s dynamic model was established. Lankarani-Nikravesh hysteretic force model was taken as the rub-impact force model. Then Runge-Kutta method was used to do numerical calculation, and study spectral characteristics and amplitude-frequency ones of the dual-rotor system. Finally, based on a dual-rotor test platform, the numerical results were partly verified with tests. Results showedthat (1) rub-impact of the dual-rotor system can generate excitation frequencies and combined frequencies, and combined resonance appears; (2) rub-impact of HP turbine can cause reverse whirl and full annular rub,and rub-impact of LP turbine can suppress rub-impact of HP turbine, sowhen HP and LP turbines rub simultaneously, compared with rub-impact of HP turbine only, the rotating speed range for the system reverse whirl is narrower and vibration amplitude is lower; (3) in process of speed up and down, rub-impact can cause single or even multiple bi-stable phenomena in the dual-rotor system.

Key words： rub-impact ofhigh pressure/low pressure (HP/LP) turbines dual-rotor system combined resonance reverse whirl bi-stable phenomenon

收稿日期: 2019-05-05 出版日期: 2021-01-15

引用本文:

聂日敏1，2，3，曹树谦1，2，3，郭虎伦1，2，3. 航空发动机双转子系统高/低压涡轮碰摩振动分析[J]. 振动与冲击, 2021, 40(1): 243-253.
NIE Rimin1,2,3, CAO Shuqian1,2,3, GUO Hulun1,2,3. Rub-impact vibration analysis of PH/LH turbines of aeroengine dual-rotor system. JOURNAL OF VIBRATION AND SHOCK, 2021, 40(1): 243-253.

链接本文:

http://jvs.sjtu.edu.cn/CN/ 或 http://jvs.sjtu.edu.cn/CN/Y2021/V40/I1/243

[1] 晏砺堂, 王德友. 航空双转子发动机动静件碰摩振动特征研究[J]. 航空动力学报, 1998, 13(2): 173-176.
YAN Li-tang, WANG De-you. vibration features from rubbing between rotor and casing for a dual-shaft aeroengine[J]. Journal of Aerospace Power, 1998(2): 173-176.
[2] SUN Chuan-zong, Chen Yu-shu, Hou Lei. Steady-state response characteristics of a dual-rotor system induced by rub-impact[J]. Nonlinear Dynamics, 2016, 86(1): 1-15.
[3] SUN Chuan-zong, Chen Yu-shu, Hou Lei. Nonlinear dynamical behaviors of a complicated dual-rotor aero-engine with rub-impact[J]. Archive of Applied Mechanics, 2018, 88(8): 1-20.
[4] 张天程, 曹树谦, 李利青, 等. 碰摩双转子系统弯扭耦合振动分析与实验[J]. 航空动力学报, 2019, 34(3): 643-655.
ZHANG Tian-cheng, CAO Shu-qian, LI Li-qin, et.al. Analysis and experimental research of coupled bending and torsional vibration of a dual-rotor system under rub-impact[J]. Journal of Aerospace Power, 2019, 34(3): 643-655.
[5] WANG Nan-fei, Jiang Dong-xiang, Behdinan K. Vibration response analysis of rubbing faults on a dual-rotor bearing system[J]. Archive of Applied Mechanics, 2017, 87(336): 1-17.
[6] YANG Yang, Cao Deng-qing, Yu Tian-hu, et al. Prediction of dynamic characteristics of a dual-rotor system with fixed point rubbing—Theoretical analysis and experimental study[J]. International Journal of Mechanical Sciences, 2016, 115: 253-261.
[7] 罗贵火, 杨喜关, 王飞. 高维双转子系统的碰摩响应特性研究[J]. 振动工程学报, 2015, 28(1):100-107.
LUO Gui-huo, YANG Xi-guan, WANG Fei. Research for response characteristics of rub-impact high dimensional dual-rotor system[J]. Journal of Vibration Engineering, 2015, 28(1):100-107.
[8] YANG Yang, Cao Deng-qing, Wang De-you, et al. Fixed-point rubbing characteristic analysis of a dual-rotor system based on the Lankarani-Nikravesh model[J]. Mechanism & Machine Theory, 2016, 103: 202-221.
[9] 欧阳运芳, 明阳. 航空发动机双转子系统碰摩故障振动特性研究[J]. 机械工程师, 2016(11): 65-71.
OUYANG Yun-fang, MING Yang. Research on Rub-impact Fault Vibration Characteristics of Aeroengine Dual-rotor System[J]. Mechanical Engineering, 2016(11): 65-71.
[10] 王四季, 廖明夫, 蒋云帆, 等. 对转双转子局部碰摩故障实验[J]. 推进技术, 2013(34): 31-36.
WANG Si-ji, LIAO Ming-fu, JIANG Yun-fan, et al. Experimental study on the local rub-impact fault of counter-rotating dual-rotor[J]. Journal of Propulsion Technology, 2013(34): 31-36.
[11] CHEN Guo. Simulation of casing vibration resulting from blade–casing rubbing and its verifications[J]. Journal of Sound & Vibration, 2016, 361:190-209.
[12] 太兴宇, 马辉, 谭祯,等. 一种新的旋转叶片-机匣碰摩表征模型[J]. 机械工程学报, 2014, 50(21): 180-188.
TAI Xing-yu, MA Hui, TAN Zhen, et al. A New Representation Model of Rotating Blade-casing Rub-impact[J]. Journal of Mechanical Engineering, 2014, 50(21): 180-188.
[13] CAO Deng-qing, Yang Yang, Chen Hua-tao, et al. A novel contact force model for the impact analysis of structures with coating and its experimental verification[J]. Mechanical Systems & Signal Processing, 2015, 35(175): 61-69.
[14] 单颖春, 刘献栋, 何田, 等. 双转子系统碰摩有限元接触分析模型及故障诊断[J]. 航空动力学报, 2005, 20(5): 789-794.
SHAN Ying-chun, LIU Xian-dong, HE Tian, et al. Dual rotor system with rub impact finite element contact analysis model and fault diagnosis[J]. Journal of Aerospace Power, 2005, 20(5): 789-794.
[15] 王国胜. 航空发动机双转子碰摩动力学研究[D]. 哈尔滨, 哈尔滨工业大学, 2010.
WANG Guo-sheng. Dynamic study of rub-impact of dual-rotor system for aero-engine[D]. Harbin, Harbin Institute of Technology, 2010.
[16] 洪杰, 马艳红, 张大义. 航空燃气轮机总体结构设计与动力学分析[M]. 北京: 北京航空航天大学出版社, 2014.
[17] 江俊, 陈艳华. 转子与定子碰摩的非线性动力学研究[J]. 力学进展, 2013, 43(1): 132-148.
JIANG Jun, CHEN Yan-hua. Advances in the research on nonlinear phenomena in rotor/stator rubbing system[J]. Advances in Mechanics, 2013, 43(1): 132-148.
[18] 丁千, 陈予恕. 转子碰摩运动的非稳态分析[J]. 航空动力学报, 2000, 15(2): 191-195.
DING Qian, Chen Yu-shu. Non-stationary analysis of rotor/casing rubbing[J]. Journal of Aerospace Power, 2000, 15(2): 191-195.
[19] ZHANG Hua-biao, Chen Yu-shu. Bifurcation analysis on full annular rub of a nonlinear rotor system[J]. Science in China Series E: Technological Sciences, 2011, 54(8):1977-1985.
[20] 张华彪. 航空发动机转子系统碰摩的非线性动力学研究[D]. 哈尔滨, 哈尔滨工业大学, 2012.
ZHANG Hua-biao. Nonlinear dynamics on impact-rub of aeroengine rotor system[D]. Harbin, Harbin Institute of Technology, 2012.