无油线性压缩机的频率特性和活塞偏移特性研究

摘要
图/表
参考文献(15)
相关文章 (15)

全文: PDF (1261 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要针对线性压缩机随工况和热负荷变化而引起共振频率和活塞中心位置偏移量改变的问题，建立了关于压缩机共振频率的线性等效模型和傅里叶变换计算模型。两种模型用来预测线性压缩机的共振频率，后者同时用来计算活塞中心位置偏移量，模型中考虑了不同行程、不同排气压力对共振频率的影响以及不同行程、不同排气压力和不同运行频率对活塞中心位置偏移量的影响。为了验证模型的有效性，本文搭建了用来测量线性压缩机共振频率和活塞中心位置偏移量的测试系统，并将测量结果与模型所计算结果进行对比，结果表明，线性等效模型相比于傅里叶变换计算模型能更加准确的预测线性压缩机的共振频率；线性压缩机的共振频率随着行程的增加而逐渐减小，随着排气压力的增加而逐渐增加。实验表明，线性压缩机活塞中心位置偏移量随行程的增加而几乎不变，随着排气压力的增加而逐渐增加。傅里叶变换计算模型针对不同行程下活塞中心位置偏移量预测值高于实际值；但在不同排气压力或不同行程下的活塞偏移量可用该模型计算压缩机在上止点位置的偏移量来进行预测，误差不大于10%。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	李诚展1
	2
	李建国2
	孙建1
	2
	蔡京辉1
	2

关键词 ：线性压缩机, 无油, 共振频率, 活塞偏移

Abstract：Here, aiming at the problem of resonance frequency and piston offset’ variation caused by working conditions and heat load’ change in linear compressor, linear equivalent model and Fourier transformation calculation one of linear compressor resonance frequency were established. Both of them were used to predict resonance frequency of linear compressor and the latter was also used to predict piston central position offset. Effects of stroke and discharge pressure on resonance frequency were considered in models, and effects of stroke, discharge pressure and operating frequency on piston offset were also considered in models. To verify the effectiveness of models, a testing system was constructed to measure resonance frequency and piston offset of linear compressor. The test results were compared with the calculated ones. Results showed that compared with Fourier transformation calculation model, the linear equivalent model can predict resonance frequency more accurately; resonance frequency gradually decreases with increase in stroke and increases with increase in discharge pressure. Tests showed that piston offset of linear compressor is almost a constant with increase in stroke and gradually increases with increase in discharge pressure; piston offset values predicted with Fourier transformation calculation model under different strokes are higher than the actual test ones, but piston offsets under different strokes and discharge pressures can be predicted by using this model to calculate the compressor’s offsets at the position of top dead center (TDC), the error is less than 10%.


Key words： linear compressor oil-free resonance frequency piston offset

收稿日期: 2086-01-29 出版日期: 2021-02-15

引用本文:

李诚展1,2,李建国2,孙建1,2,蔡京辉1,2. 无油线性压缩机的频率特性和活塞偏移特性研究[J]. 振动与冲击, 2021, 40(3): 133-138.
LI Chengzhan1,2, LI Jianguo2, SUN Jian1,2, CAI Jinghui1,2. Frequency characteristics and piston offset characteristics of oil-free linear compressor. JOURNAL OF VIBRATION AND SHOCK, 2021, 40(3): 133-138.

链接本文:

http://jvs.sjtu.edu.cn/CN/ 或 http://jvs.sjtu.edu.cn/CN/Y2021/V40/I3/133

[1] Barbosa J R, Ribeiro G B, de Oliverira P A. A State-of-the-Art Review of Compact Vapor Compression Refrigeration Systems and Their Applications [J]. Heat Transfer Engineering, 2012, 33(4-5):357-374.
[2] Liang K, Stone R, Dadd M, et al. A novel linear electromagnetic-drive oil-free refrigeration compressor using R134a [J]. International Journal of Refrigeration, 2014, 40(3):450-459.
[3] 岳向吉，巴德纯，苏征宇，等. 基于CFD的滚动活塞压缩机泵腔气流噪声分析[J]. 振动与冲击，2012，31(3): 123-126.
Yue X J, Ba D C, Su Z Y, et al. Gas flow noise analysis in pump chamber of rolling piston compressors based on CFD [J]. Journal of Vibration and Shock, 2012, 31(3): 123-126.
[4] Lee H, Ki S H, Jung S S, et al. The innovative green technology for refrigerators development of innovative linear compressor[C]. Proceedings International Compressor Engineering Conference, West Lafayette, IN, USA: Purdue University, 2008: paper 1867.
[5] Spoor P S, Corey J A. A novel method for controlling piston drift in devices with clearance seals [M]. New York, Plenum Press, 2004, pp. 215–223.
[6] 何志龙，李连生，束鹏程. 冰箱用直线压缩机研究[J]. 西安交通大学学报，2003,37(11): 1119-1123.
He Z L, Li L S, Shu P C. Study on linear compressor for household refrigerator[J]. Journal of Xi’an Jiaotong University, 2003, 37(11): 1119-1123.
[7] Schmidt T E. Oscillating compressors in refrigerators [J]. Kaeltetechnik, 1956, 8(3): 93-99.
[8] 谢洁飞.动磁式线性压缩机理论与试验研究[D].杭州：浙江大学，2005.
Xie J F.Theoretical and experimental investigation of moving magnet linear compressor [D].Hangzhou, Zhejiang University,2005.
[9] 赵科. 冰箱用动磁铁式直线压缩机动态优化设计的关键问题研究[D].杭州：浙江大学，2014.
Zhao K. Research on key issues of dynamic optimum design of moving-magnet-iron linear compressor for refrigerator [D]. Hangzhou: Zhejiang University, 2014.
[10] Bradshaw C R, Groll E A, Garimella S V. A comprehensive model of a miniature-scale linear compressor for electronics cooling [J]. International Journal of Refrigeration, 2011, 34: 63-73.
[11] Choe G S, Kim K J. Analysis of nonlinear dynamics in a linear compressor [J]. JSME International Journal Series C-Mechanical Systems Machine Elements and Manufacturing, 2000, 43(3): 545-552.
[12] Cadman R, Cohen R. Electrodynamic oscillating compressor: part 1 design based on linearized loads [J]. ASME Journal of Basic Engineering, 1969, 91(4):656-663.
[13] 师汉民，黄其柏. 机械振动系统[M]. 武汉：华中科技大学出版社，2013.
Shi H M, Huang Q B. Mechanical vibrating system[M]. Wuhan: Huazhong University of Science and Technology Press, 2013.
[14] 唐明生. 线性压缩机非线性特性与控制系统研究[D]. 北京：中国科学院大学，2014.
Tang M S. Research on nonlinear characteristic and control system of linear compressor [D]. Beijing: University of Chinese Academy of Sciences, 2014.
[15] Bradshaw C R, Groll E A, Garimella S V. Linear compressors for electronics cooling: energy recovery and its benifits [J]. International Journal of Refrigeration, 2013, 36: 2007-2013.