高压水射流冲击作用下煤-砂岩-页岩损伤破裂特征

摘要
图/表
参考文献(27)
相关文章 (15)

全文: PDF (4056 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要高压水射流技术作为一种高效开采油气资源的方法已广泛应用于资源开采领域，考虑到高压水射流冲击下非常规油气储层岩破坏特征的不同，以具有代表性的煤、砂岩、页岩为研究对象，开展水射流破岩试验，采用扫描电子显微镜、CT和核磁共振技术分析煤岩破坏形式、微观破坏形貌和孔隙结构变化。结果表明，在相同试验参数条件下，高压水射流冲击下三种岩体破坏特征具有明显差别，在破坏模式上冲蚀后煤体以水楔作用主导的纵向劈裂为主，砂岩以射流的剥蚀破坏主导的“纺锤形”破碎坑为主，而页岩以应力波和水楔作用造成的浅部横向环状裂纹及底部的纵向劈裂破坏为主。损伤程度上，煤体不同深度截面损伤度在10%以内波动，砂岩仅破碎坑处具有微弱损伤，页岩浅部损伤严重，最大可达70%。冲蚀前后的孔隙检测表明，冲蚀后煤体内大孔是冲蚀前的8倍，冲蚀后砂岩内部微孔大量转化为中孔，页岩内部大孔显著增加约为冲蚀前的300倍。冲蚀后的微观断裂机制表现出，煤体表面留有晶体断裂痕迹；砂岩冲蚀面岩石碎屑大量减少，留有大量孔隙；页岩冲蚀面上可见整齐晶体拉伸断裂痕迹。研究结果可为水射流提高非常规天然气储层岩破碎效率提供理论指导。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	葛兆龙1
	2
	赵汉云1
	2
	卢义玉1
	2
	肖宋强1
	2
	周哲1
	2
	博涛3

关键词 ：高压水射流, 非常规油气储层, 损伤破坏, 微观断裂, 孔隙

Abstract：High pressure water jet technology is widely used in field of resource exploitation as an efficient method to exploit oil and gas resources. Here, considering different destruction characteristics of unconventional oil and gas reservoir rock under impact of high-pressure water jet, taking representative coal, sandstone and shale as study objects, water jet rock breaking tests were conducted, and coal rock failure mode, morphology of micro-destruction and pore structure change were analyzed using the scanning electron microscope, CT and nuclear magnetic resonance technology. The results showed that under the same test parameters, failure characteristics of 3 kinds of rock body under high-pressure water jet impact are obviously different, coal body after erosion is dominated by longitudinal splitting due to water wedge leading action, sandstone is dominated by "spindle" fracture pits due to jet erosion leading action, and shale is dominated by shallow transverse annular cracks and bottom longitudinal splitting caused by stress wave and water wedge; damage degree of different depth sections of coal body fluctuates within 10%, only weak damage exists at fracture pits of sandstone, and serious damage exists in shallow part of shale, the maximum is up to 70%; macropores in coal body after erosion are 8 times of those before erosion, a large number of micro-pores in sandstone are changed into mesopores after erosion, and macropores in shale significantly increase, their number after erosion is about 300 times of that before erosion; for micro- fracture mechanism after erosion, there are traces of crystal fracture on coal body surface, rock bits on erosion surface of sandstone are greatly reduced and a large number of pores are left, traces of uniform crystal tensile fracture can be seen on erosion surface of shale; the study results can provide a theoretical guidance for using water jet to improve crushing efficiency of unconventional natural gas reservoir rock.

Key words： high-pressure water jet unconventional oil and gas reservoir damage failure micro-fracture pore

收稿日期: 2020-03-18 出版日期: 2021-07-15

引用本文:

葛兆龙1,2，赵汉云1,2，卢义玉1,2，肖宋强1,2，周哲1,2，博涛3. 高压水射流冲击作用下煤-砂岩-页岩损伤破裂特征[J]. 振动与冲击, 2021, 40(13): 174-181.
GE Zhaolong1,2, ZHAO Hanyun1,2, LU Yiyu1,2, XIAO Songqiang1,2, ZHOU Zhe1,2, BO Tao3. Damage and fracture characteristics of coal-sandstone-shale under high pressure water jet impact. JOURNAL OF VIBRATION AND SHOCK, 2021, 40(13): 174-181.

链接本文:

http://jvs.sjtu.edu.cn/CN/ 或 http://jvs.sjtu.edu.cn/CN/Y2021/V40/I13/174

［1］MOMBER A W. An SEM-study of high-speed hydrodynamic erosion of cementitious composites［J］. Composites Part B: Engineering, 2003,34(2): 135-142.
［2］刘佳亮,李坤元,张娣.高压水射流冲蚀混凝土破碎区演进特征及裂纹扩展规律研究［J］.振动与冲击,2019,38(24):131-137.
LIU Jialiang, LI Kunyuan, ZHANG Di.Study on the evolution characteristics and crack propagation law of high pressure water jet eroded concrete crushing zone ［J］ .Journal of Vibration and Shock, 2019,38 (24): 131-137.
［3］苏佳纯, 张金川, 朱伟林. 非常规天然气经济评价对策思考［J］. 天然气地球科学, 2018,29(5): 743-753.
SU Jiachun, ZHANG Jinchuan, ZHU Weilin. Thinking on economic evaluation of unconventional natural gas［J］. Natural Gas Geoscience, 2018,29(5): 743-753.
［4］THOMAS S, ANTONY M, DIMITRA T, et al. Hard rock cutting with high pressure jets in various ambient pressure regimes［J］. International Journal of Rock Mechanics and Mining Sciences, 2018,108: 179-188.
［5］刘佳亮,张娣,王梦瑾.水力冲击混凝土裂纹扩展机理及CT尺度损伤研究［J］.振动与冲击,2019,38(11):68-74.
LIU Jialiang, ZHANG Di, WANG Mengjin.Research on crack growth mechanism and CT scale damage of hydraulic impact concrete ［J］.Journal Vibration and Shock, 2019,38 (11): 68-74.
［6］DEHKHODA S, HOOD M. The internal failure of rock samples subjected to pulsed water jet impacts［J］. International Journal of Rock Mechanics and Mining Sciences, 2014,66: 91-96.
［7］HARRIS H D, MELLOR M. Cutting rock with water jets［J］. International Journal of Rock Mechanics and Mining Sciences & Geomechanics Abstracts, 1974,11(9): 343-358.
［8］MOMBER A W. Wear of rocks by water flow［J］. International Journal of Rock Mechanics and Mining Sciences, 2004,41(1): 51-68.
［9］梁运培. 高压水射流钻孔破煤机理研究［D］. 青岛：山东科技大学, 2007.
［10］陆朝晖,卢义玉,HOOD M,等.截断式脉冲射流流场结构模拟与冲蚀硬岩能力分析［J］.振动与冲击,2017,36(19):180-185.
LU Zhaohui, LU Yiyu, HOOD M, et al. Simulation of flow field structure and analysis of erosion hard rock capacity of truncated pulse jet ［J］. Journal Vibration and Shock, 2017, 36 (19): 180-185.
［11］黄飞, 卢义玉, 刘小川, 等. 高压水射流冲击作用下横观各向同性岩石破碎机制［J］. 岩石力学与工程学报, 2014,33(7): 1329-1335.
HUANG Fei, LU Yiyu, LIU Xiaochuan, et al. The mechanism of transversely isotropic rock fracture under the impact of high pressure water jet ［J］. Journal of Rock Mechanics and Engineering, 2014,33(7): 1329-1335.
［12］BROOK N, SUMMERS D A. The penetration of rock by high-speed water jets［J］. International Journal of Rock Mechanics and Mining Sciences & Geomechanics Abstracts, 1969,6(3): 249-258.
［13］李根生, 廖华林, 黄中伟, 等. 超高压水射流作用下岩石损伤破碎机理［J］. 机械工程学报, 2009,45(10): 284-293.
LI Gensheng, LIAO Hualin, HUANG Zhongwei, et al. Damage mechanism of rock under the action of ultra-high pressure water jet［J］. Journal of Mechanical Engineering, 2009,45(10): 284-293.
［14］盛茂, 田守嶒, 李根生, 等. 高压水射流冲蚀作用下页岩破坏模式与力学机制［J］. 中国科学:物理学力学天文学, 2017,47(11): 99-106.
MAO Sheng, TIAN Shouceng, LI Gensheng, et al. Destruction mode and mechanical mechanism of shale under high pressure water jet erosion［J］. Science in China: Physics Mechanics Astronomy, 2017,47(11): 99-106.
［15］倪红坚, 王瑞和. 高压水射流射孔过程及机理研究［J］. 岩土力学, 2004(增刊1): 29-32.
NI Hongjian, WANG Ruihe. Study on perforation process and mechanism of high pressure water jet［J］. Rock and Soil Mechanics, 2004(Sup 1): 29-32.
［16］NI H J, WANG R H, ZHANG Y Q. Numerical simulation study on rock breaking mechanism and process under high pressure water jet［J］. Applied Mathematics and Mechanics, 2005, 26:1595-1604.
［17］BATTISTIN D, LAFRATI A. A numerical model for the jet flow generated by water impact［J］. Journal of Engineering Mathematics, 2004, 48:353-374.
［18］XIAO Songqiang, GE Zhaolong, LU Yiyu, et al. Investigation on coal fragmentation by high-velocity water jet in drilling: size distributions and fractal characteristics［J］. Applied Sciences, 2018,8(10): 1988.
［19］SONG Chenpeng, LU Yiyu, TANG Hongmei, et al. A method for hydrofracture propagation control based on non-uniform pore pressure field［J］. Journal of Natural Gas Science and Engineering, 2016,33: 287-295.
［20］司鹄,薛永志,周维.自激振荡脉冲射流破岩效率数值模拟［J］.振动与冲击,2016,35(20):149-153.
SI Hu, XUE Yongzhi, ZHOU Wei.Numerical simulation of rock breaking efficiency of self-excited oscillating pulse jet ［J］ .Journol of Vibration and Shock, 2016,35(20): 149-153.
［21］LU Y Y, HUANG F, LIU X C, et al. On the failure pattern of sandstone impacted by high-velocity water jet［J］. International Journal of Impact Engineering, 2015, 76:67-74.
［22］代世峰, 周义平, 任德贻, 等. 重庆松藻矿区晚二叠世煤的地球化学和矿物学特征及其成因［J］. 中国科学D辑:地球科学, 2007(3): 353-362.
DAI Shifeng, ZHOU Yiping, REN Deyi, et al. Geochemical and mineralogical characteristics and genesis of late permian coal
in Songzao Mining Area, Chongqing［J］. Science in China, Series D: Earth Science, 2007(3): 353-362.
［23］LU Yiyu, AO Xiang, TANG Jiren, et al. Swelling of shale in supercritical carbon dioxide［J］. Journal of Natural Gas Science and Engineering, 2016,30: 268-275. 
［24］XUE Y Z, SI H, HU Q T. The propagation of stress waves in rock impacted by a pulsed water jet［J］. Powder Technology, 2017, 320:179-190.
［25］LI Xin, FU Xuehai, RANJITH P G, et al. Stress sensitivity of medium- and high volatile bituminous coal: an experimental study based on nuclear magnetic resonance and permeability-porosity tests［J］. Journal of Petroleum Science and Engineering, 2019,172: 889-910.
［26］LU Yiyu, CHEN Xiayu, TANG Jiren, et al. Relationship between pore structure and mechanical properties of shale on supercritical carbon dioxide saturation［J］. Energy, 2019,172: 270-285.
［27］GAO Hui, LI Huazhou. Determination of movable fluid percentage and movable fluid porosity in ultra-low permeability sandstone using nuclear magnetic resonance (NMR) technique［J］. Journal of Petroleum Science and Engineering, 2015,133: 258-267.