开放式水泵旋转双隔舌蜗壳内压力脉动特性的试验研究

摘要
图/表
参考文献(20)
相关文章 (15)

全文: PDF (3007 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要为了揭示新型开放式水泵旋转双隔舌蜗壳内压力脉动特性和规律，以水槽式洗碗机关键核心部件-开放式水泵为研究对象，基于创新的旋转压力脉动测试技术和设备，首次得到双隔舌蜗壳被动旋转、不同叶轮转速以及不同水位下监测点的脉动时域信号，并进行频域分析。试验结果表明：蜗壳被动旋转过程中消耗能量，导致蜗壳被动旋转时压力脉动平均幅值小于蜗壳静止时的压力脉动平均幅值。由于蜗壳中隔舌的周期设计，在叶轮旋转一周的时间内，压力脉动曲线出现2倍叶片数的波峰和波谷。与蜗壳静止相比，蜗壳被动旋转过程中叶轮与蜗壳的相对速度减小，这使得在叶轮转速为2000rpm、2200rpm、2400rpm以及2600rpm时，蜗壳旋转时的压力脉动主频略小于蜗壳静止时的压力脉动主频。脉动强度与监测点位置相关，位于后泵腔位置监测点压力存在负值，靠近出口位置监测点受到蜗壳喷淋臂上喷嘴射流的影响，脉动曲线变得紊乱，监测点距离复合式叶轮越远，脉动振幅越小。泵在低水位运行时，泵内进入空气，脉动曲线周期性不明显，此时脉动主频为1倍轴频。水位越高，蜗壳被动旋转过程中受到阻力越大，导致脉动主频在水位48mm和66mm时分别为2倍叶频和1倍叶频。本试验采用的旋转测试装置解决了旋转时压力脉动测试问题，为类似问题提供参考。
关键词：开放式水泵；双隔舌蜗壳；压力脉动；轴频；叶频；蜗壳被动旋转

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	张金凤1
	朱益磊1
	李亚林1
	2
	黄萍1
	徐慧2
	郑峰2

关键词 ：开放式水泵, 双隔舌蜗壳, 压力脉动, 轴频, 叶频, 蜗壳被动旋转

Abstract：In order to reveal the new open water pump rotate inside the double volute tongue insulation pressure pulsation characteristics and features, with water tank type dishwasher key core components in open water pump as the research object, based on the innovation of the rotation pressure pulsation test technology and equipment, for the first time get double volute tongue passive isolation and rotating, different impeller speed under different water level monitoring pulse time domain signal, line frequency domain analysis. The test results showed that the volute consumes energy in the process of passive rotation, which results in that the average amplitude of pressure pulsation when the volute is passive rotation is less than that when the volute is stationary. Due to the periodic design of the tongue in the volute, the peak and trough of the pressure pulsation curve appear twice the number of blades within the time of the impeller's rotation. Compared with the stationary volute, the relative velocity between the impeller and the volute decreases during the passive rotation of the volute, which makes the main frequency of pressure pulsation when the volute rotates slightly smaller than that when the volute is stationary when the impeller speed is 2000rpm, 2200rpm, 2400rpm and 2600rpm. The pulsation intensity is related to the position of the monitoring point. The pressure of the monitoring point at the position of the rear chamber has a negative value, and the monitoring point near the outlet is affected by the jet flow of the nozzle on the volute spray arm, and the pulsation curve becomes chaotic. The farther the monitoring point is from the impeller, the smaller the pulsation amplitude. When the pump runs at low water level, the air enters the pump, and the periodicity of the pulsation curve is not obvious. At this time, the main frequency of the pulsation is 1 times the shaft frequency. The higher the water level is, the more resistance the volute is subjected to during passive rotation, resulting in the main frequency of pulsation being double blade frequency and double blade frequency respectively at the water level of 48mm and 66mm.The rotating test device used in this test solves the pressure pulsation test problem during rotation and provides reference for similar problems.
Key words: open water pump; Double tongue volute; Pressure pulsation; Shaft frequency; blade frequency; Passive rotation of volute

Key words： open water pump Double tongue volute Pressure pulsation Shaft frequency blade frequency Passive rotation of volute

收稿日期: 2021-05-25 出版日期: 2022-12-15

引用本文:

张金凤1，朱益磊1，李亚林1,2，黄萍1，徐慧2，郑峰2. 开放式水泵旋转双隔舌蜗壳内压力脉动特性的试验研究[J]. 振动与冲击, 2022, 41(23): 60-66.
ZHANG Jinfeng1, ZHU Yilei1, LI Yalin1,2, HUANG Ping1, XU Hui2, ZHENG Feng2. Tests for pressure pulsation characteristics in rotating dual-tongue volute of open water pump. JOURNAL OF VIBRATION AND SHOCK, 2022, 41(23): 60-66.

链接本文:

http://jvs.sjtu.edu.cn/CN/ 或 http://jvs.sjtu.edu.cn/CN/Y2022/V41/I23/60

[1]赵万勇，马得东，史凤霞，等. 蜗壳形状对液力透平压力脉动影响的研究[J]. 流体机械，2020，48(11)：25-31.
ZHAO Wang-yong, MA De-dong, SHI Feng-xia, et al. Investigation on the Influence of Volute Shape on Pressure Pulsation of Hydraulic Turbine [J]. Fluid Machinery, 2020, 48(11): 25-31.
[2]王文杰，邓起凡，裴吉，等. 双吸离心泵压力脉动特性数值模拟及试验研究[J]. 振动与冲击，2020，39(19)：107-113+120.
WANG Wen-jie, DENG Qi-fan, PEI Ji, et al. Numerical simulation and tests for pressure fluctuation characteristics in a double-suction centrifugal pump [J]. Journal of Vibration and Shock, 2020, 39(19): 107-113+120.
[3]张德胜，王超超，董亚光，等. 高比转速斜流泵内部压力脉动特性的实验研究[J]. 振动与冲击，2019， 38(09)：27-34.
ZHANG De-sheng, WANG Chao-chao, DONG Ya-guang, et al. Tests for inner pressure fluctuation features in an oblique flow pump with high ratio rotating speed [J]. Journal of Vibration and Shock, 2019, 38(09): 27-34.
[4] YANG Y, ZHOU L, SHI W D, et al. Interstage difference of pressure pulsation in a three-stage electrical submersible pump [J]. Journal of Petroleum Science and Engineering, 2021, 196.
[5] ZHANG N, GAO B, WANG X J, et al. Effects of cutting the blade on the performance and pressure pulsation of a centrifugal pump [J]. Energy Science & Engineering, 2020, 8(5): 1510-1523.
[6]姚志峰，王福军，肖若富，等. 离心泵压力脉动测试关键问题分析[J]. 排灌机械工程学报，2010，28(03)：219-223.
YAO Zhi-feng, WANG Fu-jun, XIAO Ruo-fu, et al. Key issues in pressure fluctuation experiments for centrifugal pumps [J]. Journal of Drainage and Irrigation Machinery Engineering, 2010, 28(03): 219-223.
[7]田锋社. 水轮机压力脉动测试的分析与探讨[J]. 水利水电科技进展，2006(02)：37-39+86.
TIAN Feng-she. Study on pressure fluctuation test of water turbine [J]. Advances in Science and Technology of Water Resources, 2006(02): 37-39+86.
[8]姚丹，卢池. 水轮机模型压力脉动的测试及分析方法[J]. 中国水能及电气化，2012(11)：61-63+60.
YAO Dan, LU Chi. Test and Analysis Method of Turbine Model Pressure Pulse [J]. China Water Power & Electrification, 2012(11): 61-63+60.
[9]李伟，季磊磊，施卫东，等. 不同流量工况下混流泵压力脉动试验[J]. 农业机械学报，2016，47(12)：70-76.
LI Wei, JI Lei-lei, SHI Wei-dong, et al. Experiment on Pressure Fluctuation in Mixed-flow Pump under Different Flow Rate Conditions [J]. Transactions of the Chinese Society of Agricultural Machinery, 2016, 47(12): 70-76.
[10]施卫东，张磊，陈斌，等. 离心泵间隙对压力脉动及径向力的影响[J]. 排灌机械工程学报，2012，30(03)：260-264.
SHI Wei-dong, JI Lei, CHEN Bin, et al. Influence of gap on pressure pulsation and radial force of centrifugal pumps [J]. Journal of Drainage and Irrigation Machinery Engineering, 2012, 30(03): 260-264.
[11]刘宜，梁润东，蒋跃，等. 单-双蜗壳泵隔舌区压力脉动及径向力特性分析[J]. 兰州理工大学学报，2014，40(04)：51-55.
LIU Yi, LIANG Run-dong, JIANG Yue, et al. Pressure fluctuation near volute tongue and analysis of radial force characteristics of single and double volute pumps [J]. Journal of Lanzhou University of Technology, 2014, 40(04):51-55.
[12]牟介刚，刘剑，郑水华，等. 隔舌对离心泵压力脉动特性及内部流场的影响[J]. 中南大学学报(自然科学版)，2016，47(12)：4090-4098.
MOU Jie-gang, LIU Jian, ZHENG Shui-hua, et al. Effect of tongue on pressure fluctuation and internal flow in centrifugal pump [J]. Journal of Central South University(Science and Technology), 2016, 47(12): 4090-4098.
[13]张帆，袁寿其，付强，等. 双蜗壳式离心泵内部非定常流动压力特性分析[J]. 农业机械学报，2015，46(02)：52-58.
ZHANG Fan, YUAN Shou-qi, FU Qiang, et al. Analysis on Pressure Characteristics during Internal Unsteady Flow in Double Volute Centrifugal Pump [J]. Transactions of the Chinese Society for Agricultural Machinery, 2015, 46(02): 52-58.
[14]王家斌，陈佳，袁寿其，等. 双吸双蜗壳离心泵隔舌处的压力脉动特性[J]. 排灌机械工程学报，2016，34(04)：283-289.
WANG Jia-bin, CHEN Jia, YUAN Shou-qi, et al. Pressure fluctuation near double volute tongue for double-suction centrifugal pump [J]. Journal of Drainage and Irrigation Machinery Engineering, 2016, 34(04): 283-289.
[15]Tran B N, JEONG H, KIM J H, et al. Effects of Tip Clearance Size on Energy Performance and Pressure Fluctuation of a Tidal Propeller Turbine[J]. Energies, 2020, 13(16).
[16]施卫东，姚捷，张德胜，等. 不同转速下轴流泵压力脉动试验[J]. 农业机械学报，2014，45(03)：66-71.
SHI Wei-dong, YAO Jie, ZHANG De-sheng, et al. Test Comparative Study on Impact of Different Revolving Speed on Pressure Fluctuation in Axial Flow Pump [J]. Transactions of the Chinese Society for Agricultural Machinery, 2014, 45(03): 66-71.
[17]张德胜，耿琳琳，施卫东，等. 轴流泵水力模型压力脉动和振动特性试验[J]. 农业机械学报，2015，46(06)：66-72.
ZHANG De-sheng, GENG Lin-lin, SHI Wei-dong, et al. Experimental Investigation on Pressure Fluctuation and Vibration in Axial-flow Pump Model [J]. Transactions of the Chinese Society for Agricultural Machinery, 2015, 46(06): 66-72.
[18]谭林伟，牛国平，施卫东，等. 不同转速下离心泵压力脉动的试验研究[J]. 南通大学学报(自然科学版)，2020，19(02)：56-63.
TAN Lin-wei, NIU Guo-ping, SHI Wei-dong, et al. Experimental Investigation of Pressure Fluctuations for Centrifugal Pumps at Different Rotational Speed [J]. Journal of Nantong University(Natural Science Edition), 2020, 19(02): 56-63.
[19]高波，王孝军，倪丹，等. 离心泵变转速压力脉动特性的试验研究[J]. 流体机械，2018，46(08)：1-5.
GAO Bo, WANG Xiao-jun, NI Dan, et al. Experimental Research on Pressure Pulsation of a Centrifugal Pump at Variable Rotating Speeds [J]. Fluid Machinery, 2018, 46(08): 1-5.
[20]杨敏，闵思明，王福军. 双蜗壳泵压力脉动特性及叶轮径向力数值模拟[J]. 农业机械学报，2009，40(11)：83-88.
YANG Min, MIN Si-ming, WANG Fu-jun. Numerical Simulation of Pressure Fluctuation and Radial Force in a Double Volute Pump [J]. Transactions of the Chinese Society for Agricultural Machinery, 2009, 40(11): 83-88.