折流板对改进型平面弹性管束换热器传热特性的影响

摘要
图/表
参考文献(21)
相关文章 (7)

全文: PDF (1389 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要基于传统平面弹性管束(PETB)换热器，通过进行结构改进，提出了一种改进型PETB换热器。研究了折流板结构参数(高度和弧度)对改进型PETB换热器传热特性的影响。结果表明：随着折流板高度增加，内部传热元件的振动强度减小，传热元件的振动强化传热性能和换热器的综合传热性能均提高。当比例因子由0.70增加到0.80时，监测点的振动幅值降低7%以上；振动条件下传热元件的平均努赛尔数提高5.50%，换热器的综合传热性能评价指标PEC提高1.42%。折流板弧度的变化影响传热元件的振动强度和传热性能，当折流板弧度为10°时，监测点的振动最剧烈，传热元件的振动强化传性能和换热器的综合传热性能均最高。与弧度为0°和20°相较，监测点的振幅最大分别提高6.27%和6.63%；振动条件下传热元件的平均努赛尔数分别提高2.91%和2.78%，换热器的综合传热性能评价指标PEC分别提高0.83%和3.23%。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	张经纬1
	季家东1
	潘玉玲1
	陈清华1
	李飞扬2

关键词 ：平面弹性管束, 换热器, 折流板, 振动强化传热

Abstract：Based on the traditional plane elastic tube bundle (PETB) heat exchanger and structural improvement, an improved PETB heat exchanger was proposed. The effect of baffle structural parameters (height and radian) on heat transfer performance of improved PETB heat exchanger were studied. The results show that with the increase of baffle height, the vibration intensity of internal heat transfer components decreases, the vibration reinforced heat transfer property of heat transfer components and the overall heat transfer property of heat exchanger improve. When the scale factor from 0.70 to 0.80, the vibration amplitude of the monitoring point decreases over 7%. The average Nusselt number of components raised by 5.50% and the performance evaluation criteria PEC raised by 1.42% under vibration condition. The variation of the radian of the baffle plate affects the vibration intensity and heat transfer performance of the heat transfer element. When the radian of the baffle is 10°, the vibration of the monitoring point is the most intense, the reinforced heat transfer property of components and the overall heat transfer property of heat exchanger are the greatest. By contrast with radian 0° and 20°, the amplitude of monitoring point increased by 6.27% and 6.63%, separately. The average Nusselt number of components under vibration condition increased by 2.91% and 2.78% separately, and the PEC increased by 0.83% and 3.23% separately.

Key words： plane elastic tube bundle heat exchanger baffle vibration enhanced heat transfer;

收稿日期: 2022-06-08 出版日期: 2023-05-28

引用本文:

张经纬1，季家东1，潘玉玲1，陈清华1，李飞扬2. 折流板对改进型平面弹性管束换热器传热特性的影响[J]. 振动与冲击, 2023, 42(10): 51-57.
ZHANG Jingwei1，JI Jiadong1，PAN Yuling1，CHEN Qinghua1，LI Feiyang2. Effect of baffles on heat transfer characteristics of improved plane elastic tube bundle heat exchanger. JOURNAL OF VIBRATION AND SHOCK, 2023, 42(10): 51-57.

链接本文:

http://jvs.sjtu.edu.cn/CN/ 或 http://jvs.sjtu.edu.cn/CN/Y2023/V42/I10/51

[1] SU Y C, Li M L, Liu M L, et al. A study of enhanced heat transfer of flow-induced vibration of a new type of heat transfer tube bundle - the planar bending elastic tube bundle [J]. Nuclear Engineering and Design. 2016, 309: 294-302.
[2] JI J D, GE P Q, LIU P, et al. Design and application of a new distributed pulsating flow generator in elastic tube bundle heat exchanger [J]. International Journal of Thermal Sciences, 2018, 130: 216-226.
[3] KOZLOV V G, VJATKIN A A, SABIROV R R, et al. Methods of experimental study of thermal convection in cavity subject to rotation and vibration [J]. MethodsX, 2019, 6: 2420-2428.
[4] JI J D, GE P Q, BI W B. Numerical analysis on shell-side flow-induced vibration and heat transfer characteristics of elastic tube bundle in heat exchanger [J]. Applied Thermal Engineering, 2016, 107: 544-551.
[5] 季家东，葛培琪，毕文波，等. 采用不同管排组合的弹性管束壳程流体诱导振动响应[J]. 西安交通大学学报，2018，52(3)：69-75.
JI Jia-dong, GE Pei-qi, BI Wen-bo, et al. Sell-side flow-induced vibration responses of elastic tube bundle based on different tube combinations [J]. Journal of Xi’an Jiaotong University, 2018, 52(3): 69-75.
[6] JI J D, ZHANG J W, LI F Y, et al. Numerical research on vibration-enhanced heat transfer of improved elastic tube bundle heat exchanger [J]. Case Studies in Thermal Engineering, 2022, 33, 101936.
[7] 闫柯. 换热器内锥螺旋弹性管束振动与传热特性研究[D]. 山东大学，2012.
YAN Ke. A study on the vibration and heat transfer characteristics of conical spiral tube bundle in heat exchanger [D]. Shandong University, 2012.
[8] JI J D, GAO R M, CHEN W Q, et al. Analysis of vortex flow in fluid domain with variable cross-section and design of a new vortex generator [J]. International Communications in Heat and Mass Transfer, 2020, 116: 104695.
[9] 季家东，张经纬，高润淼，等. 脉动流发生装置诱导弹性管束振动的试验研究[J]，振动与冲击. 2021，40(3)：291-296.
JI Jia-dong, ZHANG Jing-wei, GAO Run-miao. Tests for pulsating flow generator-induced vibration of elastic tube bundle [J]. Journal of Vibration and Shock, 2021, 40(3): 291-296.
[10] 季家东，葛培琪，毕文波. 换热器内多排弹性管束壳程流体诱导振动响应的数值分析[J]. 振动与冲击，2016，35(20)：85-89.
JI Jia-dong, GE Pei-qi, BI Wen-bo. Numerical analysis on shell-side flow induced vibration responses of multi-row elastic tube bundles in heat exchangers [J]. Journal of Vibration and Shock, 2016, 35(20): 85-89.
[11] DUAN D R, GE P Q, BI W B. Numerical investigation on heat transfer performance of planar elastic tube bundle by flow-induced vibration in heat exchanger [J]. International Journal of Heat and Mass Transfer, 2016, 103: 868-878.
[12] DUAN D R, GE P Q, BI W B, et al. Numerical Investigation on The Heat Transfer Enhancement Mechanism of Planar Elastic Tube Bundle By Flow-induced Vibration [J]. International Journal of Thermal Sciences, 2017, 112: 450-459.
[13] GOVINDARAJ K, RAVICHANDRAN S, PONNUKUTTI D, et al, Numerical analysis of baffle cut on shell side heat exchanger performance with inclined baffles [J]. Heat Transfer Engineering. 2017, 39:1156-1165.
[14] CHEN J, LI N Q, DING Y, et al. Experimental thermal-hydraulic performances of heat exchangers with different baffle patterns [J]. Energy, 2020, 205: 118066.
[15] WANG K, LIU J Q, LIU Z C, et al. Fluid flow and heat transfer characteristics investigation in the shell side of the branch baffle heat exchanger [J]. Journal of Applied Fluid Mechanics, 2021, 14(6): 1775-1786.
[16] JI J D, GAO R M, SHI B J, et al. Improved tube structure and segmental baffle to enhance heat transfer performance of elastic tube bundle heat exchanger [J]. Applied Thermal Engineering, 2022, 200: 117703.
[17] WEBB, R L, Performance Evaluation Criteria for Use of Enhanced Heat Transfer Surfaces in Heat Exchanger Design [J]. International Journal of Heat and Mass Transfer, 1981, 24(4): 715-726.
[18] 宿艳彩. 弹性管束流体诱导振动及传热特性研究[D]. 山东大学，2012：45-49.
SU Yan-cai, A Study on the Characteristic of the Flow-Induced Vibration and Heat Transfer of Elastic Tube Bundle [D]. Shandong University, 2012.
[19] SALIMPOUR M R, Heat transfer coefficients of shell and coiled tube heat exchangers [J], Experimental Thermal and Fluid Science, 2009 33(2): 203-207.
[20] 季家东. 弹性管束换热器壳程分布式脉动流诱导管束振动研究[D]. 山东大学，2016.
JI Jia-dong, Study on flow-induced vibration of elastic tube bundle with shell-side distributed pulsating flow in heat exchanger [D]. Shandong University, 2016.
[21] 陈卫强. 换热器内改进型平面弹性管束振动及传热特性分析[D]. 安徽理工大学，2022.
CHEN Wei-qiang Analysis of vibration and heat transfer characteristics of a improved planar elastic tube bundle in heat exchanger [D]. AnHui University of Science and Technology, 2022.