颗粒冲击形式对阻尼器能量损耗影响的研究

摘要
图/表
参考文献(22)
相关文章 (15)

全文: PDF (1858 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要为揭示冲击形式与损耗功率之间的依赖关系，基于离散单元法复现圆柱形和圆台形容器内颗粒的运动形式，探究由颗粒运动形式不同而造成的冲击形式以及能量损耗的差异。结果表明，相比于圆柱形容器，圆台形容器内颗粒的运动存在明显的区域特性，这种特殊的运动形式对冲击力周期分岔具有一定的抑制作用，使其对系统的冲击形式呈“小而密”型。耗能结果显示，这种“小而密”型冲击方式所产生的能量损耗要高于圆柱形内“大而疏”型冲击形式，并且二者的耗能差值会随着振动强度的提高而增大。通过分析容器倾角的渐变过程进一步验证了冲击形式对损耗功率的显著影响。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	宋晓宇
	尹忠俊
	陈兵

关键词 ：颗粒阻尼, 冲击形式, 能量耗散, 圆台形容器

Abstract：In order to reveal the dependence between the impact forms and the loss power, the motion patterns of the particles in cylinder and conical containers were reproduced through the discrete element method, and the difference between the impact forms and the energy loss caused by different forms of particle motion was explored.The results show that compared with a cylinder container, the movement of the particles in a conical container has obvious regional characteristics.This special form of motion has a certain inhibitory effect on the impact subharmonic bifurcations, so that the impact form on the system is expressed as “Small and dense” type.The energy consumption results show that the energy loss caused by this “small and dense” impact mode is higher than that of the “large and sparse” type of impact in the cylinder container, and the energy consumption difference between the two increases with the vibration intensity.The significant effect of the impact form on the power loss is further verified by analyzing the gradual process of the container inclination.

Key words： particle damping impact forms energy dissipation conical container

收稿日期: 2018-06-26 出版日期: 2019-12-15

引用本文:

宋晓宇，尹忠俊，陈兵. 颗粒冲击形式对阻尼器能量损耗影响的研究[J]. 振动与冲击, 2019, 38(24): 138-143.
SONG Xiaoyu，YIN Zhongjun，CHEN Bing. A study on the effects of particle impact forms on energy dissipation of dampers. JOURNAL OF VIBRATION AND SHOCK, 2019, 38(24): 138-143.

链接本文:

http://jvs.sjtu.edu.cn/CN/ 或 http://jvs.sjtu.edu.cn/CN/Y2019/V38/I24/138

[1] 鲁　正，吕西林，闫维明. 颗粒阻尼技术的研究综述[J]. 振动与冲击，2013, 32(7):1-7.
LU Zheng, LU Xi-lin, YAN Wei-ming. A survey of particle damping techology [J]. Journal of vibration and shock, 2013,32 (7) 1-7.
[2] Saeki M. Analytical study of multi-particle damping [J]. Journal of Sound and Vibration, 2005, 281(3-5):1133-1144.
[3] Minchael Yichuang Yang, Development of Master Design Curves for Particle Impact Dampers [D]. The Pennsylvania State University, 2003.
[4] Wong C X, Daniel M C, Rongong J A. Energy dissipation prediction of particle dampers [J]. Journal of Sound and Vibration, 2009, 319(1): 91-118.
[5] 毛宽民，陈天宁，黄协清. 非阻塞性微颗粒阻尼机理的散体元研究[J]. 西安交通大学学报，1999,33(09):80-84+89.
MAO Kuan-min, CHEN Tian-ning, HUANG Xie-qing. Mechanism of Non-Obstructive Particle Damping with Discrete Element Method [J]. Journal of XI’AN JiaoTong University, 1999, 33(09): 80-84+89.
[6] 毛宽民，陈天宁，黄协清. 非阻塞性微颗粒阻尼的散体元模型[J]. 西安交通大学学报，1999,33(05):81-85.
MAO Kuan-min, CHEN Tian-ning, HUANG Xie-qing. Discrete Element Method Applied to Non-Obstructive Particle Damping [J]. Journal of XI’AN JiaoTong University, 1999, 33(05): 81-85.
[7] 姚冰，陈前，项红荧，等. 颗粒阻尼器近似理论模型研究[J]. 机械工程学报，2015,51(03):87-94.
YAO Bing, CHEN Qian, XIANG Hong-ying,et al. Investigation on Particle Damper Based on an Approximate Theoretical Model [J]. Journal of Mechanical Engineering, 2015, 51(03): 87-94.
[8] 段勇，陈前，周宏伟. 垂直简谐激励下颗粒阻尼耗能特性的仿真研究[J]. 振动与冲击，2009,28(02):28-31+35+198.
DUAN Yong, CHEN Qian, ZHOU Hong-wei. Simulation investigation on particle damping for its characteristic of loss power under vertical excitation [J]. Journal of vibration and shock, 2009, 28(02):28-31+35+198.
[9] 段勇，陈前，林莎. 颗粒阻尼对直升机旋翼桨叶减振效果的试验[J]. 航空学报，2009,30(11):2113-2118.
Duan Yong, Chen Qian, Lin Sha. Experiments of Vibration Reduction Effect of Particle Damping on Helicopter Rotor Blade [J]. Acta Aeronautica et Astronautica Sinica, 2009, 30(11): 2113-2118.
[10] 胡溧，黄其柏，柳占新，等. 颗粒阻尼的动态特性研究[J]. 振动与冲击，2009,28(01):134-137+201.
HU Li, HUANG Qi-bai, LIU Zhan-xin,et al. Dynamic Characterstics of Particle Dampers [J]. Journal of vibration and shock, 2009, 28(01):134-137+201.
[11] 胡溧，唐喆，徐贤，等. 颗粒阻尼器损耗因子外因特性研究[J]. 中国机械工程，2015,26(15):2005-2009.
HU Li, TANG Zhe, XU Xian,et al. Study on External Features of Particle Damping Loss Factor [J]. China Mechanical Engineering, 2015, 26(15):2005-2009.
[12] 鲁正,陈筱一,王佃超,等. 颗粒调谐质量阻尼器减震控制的数值模拟[J]. 振动与冲击，2017,36(03):46-50.
LU Zheng, CHEN Xiao-yi, WANG Dian-chao,et al. Numerical simulation for vibration reduction control of particle tuned mass dampers [J]. Journal of vibration and shock, 2017,36(03):46-50.
[13] 鲁正,王佃超,吕西林. 颗粒调谐质量阻尼系统对高层建筑风振控制的试验研究[J]. 建筑结构学报，2015,36(11):92-98.
LU Zheng, WANG Dian-chao, LU Xi-lin. Experimental study on wind-induced vibration control of particle tuned mass damper system on high-rise buildings [J]. Journal of Building Structures, 2015,36(11):92-98.
[14] 赵玲，刘平，卢媛媛. 非阻塞性微颗粒阻尼柱阻尼特性的实验研究[J]. 振动与冲击，2009,28(08):1-5+195.
ZHAO Ling, LIU Ping, LU Yuan-yuan. Experimental investigation on damping characteristics of NOPD columns [J]. Journal of vibration and shock, 2009, 28(08):1-5+195.
[15] 韩红. 填隙气体对受振颗粒倍周期分岔过程影响机制研究[D]. 哈尔滨工业大学，2014.
HAN Hong. Mechanism of Interstitial Gas on Period-doubling Bifurcations in Vibrated Granular Matter [D]. Harbin Institute of Technology, 2014.
[16] 姜泽辉，王运鹰，吴晶. 窄振动颗粒床中的运动模式[J]. 物理学报，2006,55(09):4748-4753.
JIANG Ze-hui, WANG Yun-ying, WU Jing. Motion Modes of Granular Particles in a Vibrating Narrow Tube [J]. Acta Physica Sinica, 2006, 55(09):4748-4753.
[17] 姜泽辉，李斌，赵海发，等. 竖直振动颗粒物厚层中冲击力分岔现象[J]. 物理学报，2005,54(03):1273-1278.
JIANG Ze-hui, Li Bin, ZHAO Hai-fa,et al. Phenomena of impact bifurcations in vertically vibrated granular beds [J]. Acta Physica Sinica, 2005, 54(03):1273-1278.
[18] Mao, K., Wang, M.Y., Xu, Z. et al. DEM simulation of particle damping [J]. Powder Technology, 2004, 142, (2): 154-165.
[19] 徐芝纶.弹性力学[M]. 北京：高等教育出版社，1990.
XU Zhi-lun. Elasticity [M]. Beijing: Higher Education Press, 1990.
[20] Gladwell G M L. 经典弹性理论中的接触问题[M]. 范天佑译. 北京：北京理工大学出版社，1988.
Gladwell G M L. Contact Problems in Classical Elasticity Theory [M]. FAN Tian-you. Beijing: Beijing Institute of Technology Press, 1988.
[21] Kruggel Emden H, Sturm M, Wirtz S, estal. Selection of an appropriate time integration scheme for the discrete element method (DEM) [J]. Computer and Chemical Engineering, 2008, 32(10):2263-2279.
[22] Bai X M, Keer L M, Wang Q J, et al. Investigation of particle damping mechanism via particle dynamics simulations [J]. Granular Matter, 2009,11:417-429.