基于统计能量法的三相感应电机定子振动建模研究

摘要
图/表
参考文献(16)
相关文章 (7)

全文: PDF (1446 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要本文采用经典统计能量法和修正的统计能量法，在11kW三相感应电机定子上开展了内损耗因子和耦合损耗因子的实验研究。结果表明电机复杂机械结构存在强耦合、非保守、间接耦合的振动传递特点。通过对比两种方法建立的统计能量模型振动预报结果和实验测试结果，验证了两种方法在弱耦合前提下，预报直接耦合振动传递的准确性。在考虑了间接耦合损耗因子后，修正的统计能量法能够极大提高间接耦合的振动预报精度，但在物理相连的强耦合振动传递方面，受限于结构刚度大、模态密度低的特点，两种方法预测振动响应偏低。此外，本文还采用商业软件VA One进行了有限元和统计能量法混合建模，预报的结构响应与实验结果吻合较好，进一步丰富了统计能量法在电机中高频振动建模方面的应用。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	李旭涵
	王星
	王东
	张贤彪

关键词 ：中高频振动, 统计能量法, 间接耦合, 非保守系统, 强耦合

Abstract：Experimental study was carried out on the internal and coupling loss factors of an 11 kW three-phase induction motor stator using the classic statistical energy analysis (SEA) and modified SEA.The results show that strong coupling and indirect coupling exist between the non-conservative motor structure subsystems.By comparing with the experimental vibration response, the predicted results based on the two SEA models have similar precision for direct vibration transmission with weak coupling.The modified SEA model can greatly improve the prediction accuracy by introducing the indirect coupling factor, which is considered to be zero in classic SEA.However, for strong coupled and physically connected subsystems, both methods predict lower vibration response than experiment due to high rigidity and lower mode count.Finally, the FE-SEA hybrid method is used with commercial software VA One, and the simulated vibration has a good agreement with experiment, which expands the application of SEA on the study of motor structures.

Key words： middle and high frequency statistical energy analysis(SEA) indirect coupling non-conservative structure strong coupling

收稿日期: 2019-09-04 出版日期: 2020-12-15

引用本文:

李旭涵，王星，王东，张贤彪. 基于统计能量法的三相感应电机定子振动建模研究[J]. 振动与冲击, 2020, 39(24): 218-224.
LI Xuhan, WANG Xing, WANG Dong, ZHANG Xianbiao. Vibration modeling study of a three-phase induction motor stator based on statistical energy analysis. JOURNAL OF VIBRATION AND SHOCK, 2020, 39(24): 218-224.

链接本文:

http://jvs.sjtu.edu.cn/CN/ 或 http://jvs.sjtu.edu.cn/CN/Y2020/V39/I24/218

[1] Lalor N. Practical considerations for the measurement of internal and coupling loss factors on complex structures[C], ISVR Technical Report No.182, June 1990.
[2] Delarere K, Iadevaia M, Heylen W, et al. Statistical energy analysis of acoustic noise and vibration for electric motors: transmission from air gap field to motor frame[C]. 34th IAS Annual Meeting, Phoenix, AZ, USA, 1999.
[3] Wang C, Lai J C S, Pulle D W J. Prediction of acoustic noise from variable-speed induction motors: deterministic versus statistical approaches[J]. IEEE Transactions Industry Application 2002, 38(4): 1037-1044.
[4] Shen L, Wu J H. Switched reluctance motor vibration prediction: from low frequency to high frequency[C]. IEEE International Conference on Electric Machines and Drives, 2009: 965-972.
[5] 鲍晓华, 刘健, 刘冰. 基于统计能量分析的汽车发电机损耗因子的讨论[J]. 电工技术学报, 2011, 26(12): 49-54.
BAO Xiao-hua, LIU Jian, LIU Bing. Discussion for loss factors of automobile alternators based on statistical energy analysis[J]. Transactions of China Electrotechnical Society, 2011, 26(12): 49-54.
[6] 孙进才，王冲，孙朝辉. 间接耦合机械结构之间的耦合损耗因子[J]. 声学学报, 1995, 20(1): 33-41.
SUN Jin-cai, WANG Chong, SUN Zhao-hui. Coupling loss factors between indirectly coupled machinery structures[J]. Acta Acustica, 1995, 20(1):33-34.
[7] 孙进才. 复杂结构的损耗因子和耦合损耗因子的测量方法[J]. 声学学报, 1995, 20(2): 127-134.
SUN Jin-cai. Measuring method of dissipation and coupling loss factors for complex structures[J]. Acta Acustica, 1995, 20(2): 127-134.
[8] 冯慧华，赵志芳，鲁守卫，等. 基于统计能量法的变速箱振动特性研究[J]. 噪声与振动控制, 2011, 10(5) :86-89.
FENG Hui-hua, Zhao Zhi-fang, Lu Shou-wei, et al. Study on gearbox vibration performance based on statistical energy analysis[J]. Noise and Vibration Control, 2011, 10 (5):86-89.
[9] 盛美萍. 非保守耦合系统的等效内损耗因子[J]. 声学学报, 1997, 22(6): 555-561.
SHENG Mei-ping. Equivalent internal loss factors for non-conservatively coupled systems[J]. Acta Acustica, 1997, 22(6): 555-561. (in Chinese).
[10] 盛美萍. 直接和间接耦合损耗因子的计算方法[J]. 噪声与振动控制, 1997, 22(6): 2-7.
SHENG Mei-ping. Calculation method of direct and indirect coupling loss factors[J]. Noise and Vibration on Control. 1997, 22(6): 2-7.
[11] 王敏庆, 盛美萍, 孙进才. 三串联非保守耦合振子功率流II: 数值分析[J]. 声学学报, 1998 23(1): 82-87.
WANG Min-qing, SHENG Mei-ping, SUN Jin-cai. Power flows of the three non-conservatively series coupled oscillators part II: Numerical analysis[J]. Acta Acustica, 1998 23(1): 82-87.
[12] 臧晓斌. 基于SEA和FE-SEA方法的浮筏隔振性能研究[D]. 华中科技大学, 2015.
ZANG Xiao-bin. Analysis of floating raft isolation system based on SEA and FE-SEA method[D]. Huazhong University of Science and Technology, 2015.
[13] 罗文俊，蒋峻楠，雷晓燕，等. 基于FE-SEA混合法的车内结构噪声预测分析[J]. 铁道学报, 2017, 39(12):137-145.
LUO Wen-jun, JIANG jun-nan, LEI Xiao-yan, et al. Prediction analysis of internal structure noise of train based on FE-SEA hybrid method[J]. Journal of The China Railway Society, 2017, 39(12):137-145.
[14] 郭云松，丁炜，周相荣，等. VA One在舱室噪声预报中的应用[J]. 噪声与振动控制, 2017, 37(4):100-104.
GUO Yun-song, DING Wei, ZHOU Xiang-rong, et al. Application of VA One in ship cabin noise prediction[J]. Noise and Vibration Control, 2017, 37(4):100-104.
[15] 孙朝晖, 孙进才, 王冲. 负损耗因子的成因分析[J]. 声学学报, 1996, 21(5): 798-804.
SUN Zhao-hui, SUN Jin-cai, WANG Chong. Analysis of causes of formation of negative loss factors[J]. Acta Acustica, 1996, 21(5): 798-804.
[16] 张永杰，肖健，韦冰峰，等. 一种新的基于脉冲激励的内损耗因子获取方法[J]. 振动与冲击, 2014, 33(12):161-164.
ZHANG Yong-jie, XIAO Jian, WEI Bing-feng, et al. A new method for estimating damping loss factor based on multi-pulse excitation[J]. Journal of Vibration and Shock, 2014, 33(12):161-164.