Abstract：Here, a contact model of 3-stator multi-DOF ultrasonic motor considering different operational conditions was established. Firstly, the basic principle and structure of a 3-DOF ultrasonic motor were introduced and its driving torque was obtained with calculation. Then, Hertz contact theory and Mindlin theory were introduced to analyze friction case considering dynamic nonlinearity of friction coefficient and nonlinear variation of friction force distribution. A new type contact model was proposed to improve the traditional linear friction model. Finally, the friction force distribution of the motor under different motion conditions was analyzed with torque relationship and friction model, and the corresponding friction force distribution diagram was drawn with the software MATLAB. The analysis results verified the rationality of the 3-DOF ultrasonic motor. It was shown that the contact state of 3-phase piezoelectric stator is determined according to driving condition and load to lay a foundation for further optimization design and performance improvement.
李争，赵亮，郭鹏,于絮泽. 考虑驱动和负载状态的三自由度超声电机接触模型研究[J]. 振动与冲击, 2021, 40(3): 172-177.
LI Zheng， ZHAO Liang， GUO Peng， YU Xuze. Contact model of 3-DOF ultrasonic motor considering driving and load conditions. JOURNAL OF VIBRATION AND SHOCK, 2021, 40(3): 172-177.
[1] Chen W，Tian X，Xue K，Chen S，Yu H. An easily fabricated linear piezoelectric actuator using sandwich longitudinal vibrators with four driving feet[J]. IEEE Access, 2018, (7):4506-4515.
[2] Spanner K，Koc B. Piezoelectric motors an overview[J], Actuators, 2016, 5(1): 1-18.
[3] Li X，Yao Z，Wu R. Modeling and analysis of stick-slip motion in a linear piezoelectric ultrasonic motor considering ultrasonic oscillation effect[J], International Journal of Mechanical Sciences, 2016, 107: 215-224.
[4] Liu Y，Yan J，Wang L，Chen W. A Two-DOF Ultrasonic Motor Using a Longitudinal–Bending Hybrid Sandwich Transducer[J], IEEE Transactions on Industrial Electronics, 2018, 66(4): 3041-3050.
[5] Liu Y，Yan J，Xu D，Chen W，Yang X，Tian X. An I-shape linear piezoelectric actuator using resonant type longitudinal vibration transducers[J], Mechatronics, 2016, 5(1): 1-18.
[6] Wang S，Rong W，Wang L，Pei Z，Sun L. Design analysis and experimental performance of a novel stick-slip type piezoelectric rotary actuator based on variable force couple driving[J], Smart Materials and Structures, 2017, 26(5): 1-9.
[7] Li J，Huang H，Zhao H. A piezoelectric-driven linear actuator by means of coupling motion[J], IEEE Transactions on Industrial Electronics, 2018, 65(3): 2458-2466.
[8] Zhang Q，Chen W，Liu Y，Liu J，Jiang Q. A frog-shaped linear piezoelectric actuator using first-order longitudinal vibration mode[J], IEEE Transactions on Industrial Electronics, 2017, 64(3): 2188-2195.
[9] Xu D，Liu Y，Liu J，Chen W. A bonded type ultrasonic motor using the bending of a crossbeam[J], IEEE Access, 2016, 4: 1109-1116.
[10] 付前卫，姚志远. 纵弯模态复合型直线超声电机定子质心振动研究[J]. 振动与冲击，2017，36(24)：124-135.
FU Qian-wei, YAO Zhi-yuan. Stator mass center’s vibration of a linear ultrasonic motor with bending and longitudinal modes [J]. Journal of vibration and shock, 2017, 36(24): 124-135.
[11] 孙 栋，王新杰，王 炅，陈 超，唐玉娟. 旋转型超声电机在冲击环境下的失效模式研究[J]. 振动与冲击，2018，37(9)：32-36.
SUN Dong, WANG Xin-jie, WANG Jiong, CHEN Chao, TANG Yu-juan. Failure modes for rotary ultrasonic motors under shock environment [J]. Journal of vibration and shock, 2018, 37(9): 32-36.
[12] 张百亮，姚志远，简 月，李晓牛. 基于弯曲模态的板形直线超声电机结构设计[J]. 振动与冲击，2019，38(1)：110-117.
ZHANG Bai-liang, YAO Zhi-yuan, JIAN Yue, LI Xiao-niu. Structural design of a novel plate-shaped linear ultrasonic motor based on bending mode [J]. Journal of vibration and shock, 2019, 38(1): 110-117.
[13] 孙 栋，唐玉娟，王 炅，王新杰. 超声电机在冲击环境中的性能研究[J]. 振动与冲击，2019，38(20)：44-50.
SUN Dong, TANG Yu-juan, WANG Jiong, WANG Xin-jie. Analysis of characteristics of an ltrasonic motor in shock environment[J]. Journal of vibration and shock, 2019, 38(20): 44-50.
[14] Shi S，Xiong H，Liu Y，Chen W，Liu J. A ring-type multi-DOF ultrasonic motor with four feet driving consistently[J]. Ultrasonics, 2017, 76: 234-244.
[15] Zhu M. Contact Analysis and Mathematical Modeling of Traveling Wave Ultrasonic Motors[J]. IEEE Transactions on Ultrasonics Ferroelectrics and Frequency Control, 2004, 51(6): 668-679.
[16] Duan W，Quek S，Lim S. Finite element solution for intermittent-contact problem with piezoelectric actuation in ring type USM[J]. Finite elements in analysis and design, 2007, 43(1): 193-205.
[17] Sun F，Qu J，Wu P. A new visco-elastic contact model of traveling wave ultrasonic motor with stator frictional layer [J]. Journal of Harbin Institute of Technology, 2007, 14(5): 705-710.
[18] 蒋春容，张津杨，陆旦宏，姚颖蓓. 摩擦层在定子上的行波超声波电机接触模型[J].微电机,2014,47(11):5-9..
