细长圆柱构件表面扰流降噪机理的研究

摘要
图/表
参考文献(17)
相关文章 (15)

全文: PDF (2163 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要通过大涡模拟结合声比拟的方法，研究长方形截面扰流条对光滑圆柱气动噪声的影响。研究中光滑圆柱直径D=0.016m，设置了四种扰流条圆柱工况，即扰流条高度直径比H/D分别为1/8,1/4,3/8和1/2。无扰流措施时，圆柱噪声源位于边界层分离点附近。在圆柱两侧设置扰流措施后，圆柱附近流域具有低湍流特性，大尺度涡结构的展向相关性被破坏，使得圆柱表面压力脉动存在较大相位差；扰流条上游出现滞留涡结构，抑制了上游分离剪切层增长，降低了圆柱上下表面压力脉动。两机制共同作用抑制了圆柱绕流噪声。当扰流条高度直径比H/D=3/8时，降噪效果最好，在主要辐射方向上，音调噪声下降了18.17dB。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	张石宸1
	王春江1
	孙向东2
	常邑2

关键词 ：圆柱绕流, 气动噪声, 扰流条, 降噪, 数值仿真

Abstract：Using large eddy simulation and acoustic analogy, the influence of rectangular strip as vortex generator on aerodynamic noise of cylinder was studied. The diameter of cylinder was 0.016m in this research. Besides, four analysis of cylinder with strips were conducted, and the height diameter ratio of strip were respectively 1/8, 1/4, 3/8 and 1/2. Without strips, the noise source of cylinder is near boundary layer separation point. After setting strips, it was found that the flow around cylinder is low-turbulent, and the transverse correlation of large scale vortex structure is destroyed resulting in large phase difference of pressure fluctuation on the surface of the cylinder. The trapped vortex structure appears in the upstream of strip, which inhibits the growth of separated shear layer and reduces pressure fluctuation on the upper and lower surfaces of cylinder. The couple of two mechanisms suppresses aerodynamic noise around cylinder. When the height diameter ratio of strip is 3/8, noise reduction measure performs best and in the main radiation direction, the tonal noise is reduced by 18.17dB.

Key words： flow past cylinder aerodynamic noise rectangular strip noise reduction numerical simulation

收稿日期: 2020-11-19 出版日期: 2022-05-28

引用本文:

张石宸1，王春江1，孙向东2，常邑2. 细长圆柱构件表面扰流降噪机理的研究[J]. 振动与冲击, 2022, 41(10): 170-176.
ZHANG Shichen1,WANG Chunjiang1,SUN Xiangdong2,CHANG Yi2. Noise reduction mechanism of the surface vortex generator set on a slender cylinder. JOURNAL OF VIBRATION AND SHOCK, 2022, 41(10): 170-176.

链接本文:

http://jvs.sjtu.edu.cn/CN/ 或 http://jvs.sjtu.edu.cn/CN/Y2022/V41/I10/170

[1] AIPENG H, YUHONG J. Numerical Investigation of Flow Control Using Vertex Generator for Landing Gear Noise Reduction[C].// 22nd AIAA/CEAS Aeroacoustics Conference, American Institute of Aeronautics and Astronautics, 2016.
[2] SIOZOS-ROUSOULIS L, LACOR C, GHORBANIASL G. A flow control technique for noise reduction of a rod-airfoil configuration[J]. Journal of Fluids and Structures, 2017, 69: 293-307.
[3] DU L, SUN X. Noise reduction by feedback rotary oscillation of a three-dimensional circular cylinder[J]. Journal of Fluids and Structures, 2019, 84: 421-439.
[4] MA R, LIU Z, ZHANG G, et al. Control of Aeolian tones from a circular cylinder using forced oscillation[J]. Aerospace Science and Technology, 2019, 94: 105370.
[5] XU C, MAO Y, HU Z. Control of cylinder wake flow and noise through a downstream porous treatment[J]. Aerospace Science and Technology, 2019, 88: 233-243.
[6] ARCONDOULIS E, LIU Y, LI Z, et al. The design and noise characteristics of a structured porous coated cylinder in uniform flow[C].// 2018 AIAA/CEAS Aeroacoustics Conference, 2018.
[7] GEYER T F, SARRADJ E. Circular cylinders with soft porous cover for flow noise reduction[J]. Experiments in Fluids, 2016, 57(3): 30.
[8] 沈国辉,张扬,郑翀,等. 光滑圆柱风噪声的降噪措施研究[J]. 振动与冲击, 2020, 39(23): 52-57.
SHEN Guo-hui, ZHANG Yang, ZHENG Chong, et al. Denoising measures against aeolian noise of smooth circular cylinders. Journal of Vibration and Shock[J], 2020, 39(23): 52-57.
[9] LI L, LIU P, XING Y, et al. Experimental investigation on the noise reduction method of helical cables for a circular cylinder and tandem cylinders[J]. Applied Acoustics, 2019, 152.
[10] 李鑫, 屈转利, 李耿,等. 高效低噪的二维翼型优化设计[J]. 振动与冲击, 2017, 36(04): 66-72.
LI Xin, QU Zhuan-li, LI Geng, et al. A numerical optimization for high efficiency and low noise airfoils. Journal of Vibration and Shock[J], 2017, 36(4): 66-72.
[11] KATO C, IIDA A, TAKANO Y, et al. Numerical prediction of aerodynamic noise radiated from low Mach number turbulent wake[C].// 31st Aerospace Sciences Meeting, 1993 : 11-14.
[12] PéROT F, GLOERFELT X, BAILLY C, et al. Numerical Prediction of the Noise Radiated by a Cylinder[C].// 9th AIAA/CEAS Aeroacoustics Conference and Exhibit, 2003.
[13] CASALINO D, JACOB M. Prediction of aerodynamic sound from circular rods via spanwise statistical modelling[J]. Journal of Sound and Vibration, 2003, 262(4): 815-844.
[14] 陈伟杰, 乔渭阳, 王良锋,等. 基于LES与FW-H方程的圆柱-翼型干涉噪声数值研究[J]. 航空动力学报, 2016, 31(9): 2146-2155.
CHEN Wei-jie, QIAO Wei-Yang, WANG Liang-feng, et al. Investigation of rod-airfoil interaction noise using large eddy simulation and FW-H equation[J]. Journal of Aerospace Power, 2016, 31(9): 2146-2155.
[15] 丁叁叁, 姚拴宝, 陈大伟. 高速磁浮列车气动升力特性[J]. 机械工程学报, 2020, 56(08): 228-234.
DING San-san, YAO Shuan-bao, CHEN Da-wei. Aerodynamic Lift Force of High-speed Maglev Train[J]. Journal of Mechanical Engineering, 2020, 56(8) : 228-234.
[16] NORBERG C. Fluctuating lift on a circular cylinder: review and new measurements[J]. Journal of Fluids and Structures, 2003, 17(1): 57-96.
[17] ACHENBACH E. Distribution of local pressure and skin friction around a circular cylinder in cross-flow up to Re = 5 × 106[J]. Journal of Fluid Mechanics, 1968, 34(4): 625-639.