基于HB-AFT方法的水电机组转子-轴承系统振动特性研究

摘要
图/表
参考文献(31)
相关文章 (15)

全文: PDF (1066 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要受电磁、机械等外激励联合作用影响，水轮发电机组转子-轴承系统运动微分方程呈强非线性特性。采用半解析半数值谐波平衡-时频域转换方法对系统周期解予以求解，并与数值计算方法所得结果进行对比。结果表明，是否考虑不平衡磁拉力作用系统呈现出截然不同的动态特性。谐波平衡-时频域转换方法可以从解析层面准确展现稳定的转子周期运动形态；对于拟周期等非稳态运动，该方法虽无法完全展现系统的动态响应，但据此得到的解析结果可用于判断转子运动趋势及振动响应成分构成，从而为水轮发电机组轴系早期故障诊断识别提供有益借鉴。
关键词：水轮发电机组；转子-轴承系统；周期解；不平衡磁拉力；谐波平衡-时频域转换方法

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	张雷克1
	原倩1
	王雪妮1
	马震岳2
	唐华林1
	张金剑1

关键词 ：水轮发电机组, 转子-轴承系统, 周期解, 不平衡磁拉力, 谐波平衡-时频域转换方法

Abstract：Under the combined action of electromagnetic and mechanical excitations, the strong nonlinear characteristics are presented in differential equation of rotor-bearing system for hydraulic generating set. The periodic solution of system is solved by means of semi-analytical and semi-numerical harmonic balance method with alternating frequency/time domain technique, which is compared with conclusion obtained by numerical method. The results show that the dynamic characteristics of system exist remarkable distinction with and without unbalanced magnetic pull. From the analytical level, the method of harmonic balance method with alternating frequency/time domain technique can accurately reveal the periodic motion of rotor. For the unsteady quasi-periodic motion, the method cannot completely present the dynamic response of system, however, the analytical results acquired through the way can be used to judge the motion trend of rotor as well as the composition of vibration composition, so as to provide a useful reference for early fault diagnosis and identification of shaft system for hydraulic generating set.
Key words: hydraulic generating set; rotor-bearing system; periodic solution; unbalanced magnetic pull; harmonic balance method with alternating frequency/time domain technique

Key words： hydraulic generating set rotor-bearing system periodic solution unbalanced magnetic pull harmonic balance method with alternating frequency/time domain technique

收稿日期: 2021-04-19 出版日期: 2022-08-28

引用本文:

张雷克1，原倩1，王雪妮1，马震岳2，唐华林1，张金剑1. 基于HB-AFT方法的水电机组转子-轴承系统振动特性研究[J]. 振动与冲击, 2022, 41(16): 26-32.
ZHANG Leike1，YUAN Qian1，WANG Xueni1，MA Zhenyue2，TANG Hualin1，ZHANG Jinjian1. A study on vibration characteristic of a rotor-bearing system for hydraulic generating set based on the HB-AFT method. JOURNAL OF VIBRATION AND SHOCK, 2022, 41(16): 26-32.

链接本文:

http://jvs.sjtu.edu.cn/CN/ 或 http://jvs.sjtu.edu.cn/CN/Y2022/V41/I16/26

[1] 宋志强, 马震岳, 张运良，等, 考虑厂房基础耦联作用的水轮发电机组轴系统动力反应分析[J]. 振动与冲击, 2008, 27(6): 158-161+195.
SONG Zhi-qiang, MA Zhen-yue, ZHANG Yun-liang, et al. Dynamic response analysis of rotor-bearing system of a generator set accounting for whole hydropower house foundation[J]. Journal of Vibration and Shock, 2008, 27(6):158-161+195.
[2] 孙万泉, 张宁. 基于MRD的水轮发电机组轴系非线性振动控制[J]. 振动与冲击, 2020, 39(1): 79-84.
SUHN Wan-quan, ZHANG Ning. Nonlinear vibration control for hydro-generator unit’s shafting based on MRD[J]. Journal of Vibration and Shock, 2020, 39(1): 79-84.
[3] 刘杨, 李炎臻, 石拓，等. 转子-滑动轴承系统不对中-碰摩耦合故障分析[J]. 机械工程学报, 2016, 52(13): 79-86.
LIU Yang, LI Yan-zhen, SHI Ta, et al. Study on misalignment-rubbing coupling fault of rotor system supported by oil film force[J]. Journal of Mechanical Engineering, 2016, 52(13): 79-86.
[4] 刘桂珍, 于影, 马晓君，等. 质量偏心影响下的碰摩转子非线性分析[J]. 中国工程机械学报, 2016, 14(1): 21-25.
LIU Gui-zhen, YU Ying, MA Xiao-jun. Nonlinear analysis on rub impact rotor with mass eccentricity[J]. Chinese Journal of Construction Machinery, 2016, 14(1): 21-25.
[5] 李自刚, 李明, 江俊. 交角不对中转子-轴承系统非线性动力学行为研究[J]. 振动工程学报, 2019, 32(3):509-516.
LI Zi-gang, LI Ming, JIANG Jun. Nonlinear dynamics of rotor-bearing systems with a fault of angular misalignment[J]. Journal of Vibration Engineering, 2019, 32(3):509-516.
[6] 宋志强, 马震岳. 考虑不平衡磁拉力的偏心转子非线性振动分析[J]. 振动与冲击, 2010, 29(8): 169-173.
SONG Zhi-qiang, MA Zhen-yue. Nonlinear vibration and analysis of an eccentric rotor with unbalance magnetic pull[J]. Journal of Vibration and Shock, 2010, 29(8): 169-173.
[7] 覃会, 郑洪波, 张志宜. 含电磁轴承的推进轴系横向振动特性研究[J]. 振动与冲击, 2018, 37(10): 129-134.
QIN Hui. ZHENG Hong-bo,ZHANG Zhi-yi. Lateral vibration of a propulsion shafting system installed with a magnetic bearing [J]. Journal of Vibration and Shock, 2018, 37(10): 129-134.
[8] 刘长利, 姚红良, 李鹤，等. 碰摩转子轴承系统的非线性动力响应行为[J]. 东北大学学报, 2003, 24(8): 802-805.
LIU Chang-li, YAO Hong-liang, LI He, et al. Nonlinear dynamical response of rotor-bearing system with rub-impact fault[J]. Journal of Northeastern University (Natural Science), 2003, 24(8): 802-805.
[9] 宋志强, 刘云贺. 考虑电磁刚度的水电机组转子轴承系统弯扭耦合振动研究[J]. 水力发电学报, 2014, 33(6): 224-231.
SONG Zhi-qiang, LIU Yun-he. Investigation of bending-torsional coupled vibration of hydrogenerators rotor-bearing system considering electromagnetic stiffness[J]. Journal of Hydroelectric Engineering, 2014, 33(6): 224-231.
[10] 刘长利, 姚红良, 张晓伟，等. 碰摩转子轴承系统非线性振动特征的实验研究[J]. 东北大学学报(自然科学版), 2003, 24(10): 970-973.
LIU Chang-li, YAO Hong-liang, ZHANG Xiao-wei, et al. Experimental investigation on nonlinear vibration characteristics of rotor-bearing system with rub-impact fault[J]. Journal of Northeastern University(Natural Science), 2003, 24(10): 970-973.
[11] 马辉, 杨健, 宋溶泽，等. 转子系统碰摩故障实验研究进展与展望[J]. 振动与冲击, 2014, 33(6): 1-12.
MA Hui, YANG Jian, SONG Rong-ze, et al. Review and prospect on the research of rub-impact experiment of rotor systems[J]. Journal of Vibration and Shock, 2014, 33(6): 1-12.
[12] 袁惠群, 闻邦椿, 王德友，等. 滚动轴承-转子-定子系统的碰摩故障分析[J]. 东北大学学报, 2003, 24(3): 244-247.
YUAN Hui-qun, WEN Bang-chun, WANG De-you, et al. Nonlinear dynamic properties of rolling bear-rotor-stator box with local rubbing[J]. Journal of Northeastern University(Natural Science), 2003, 24(3): 244-247.
[13] 王善永, 陆颂元, 马元奎，等. 汽轮发电机组转子动静碰摩故障检测的小波分析方法研究[J]. 中国电机工程学报, 1999, 19(3): 2-6.
WANG Shan-yong, LU Song-yuan, MA Yuan-kui, et al. Application of wavelets to turbogenarator unit for impace fault detection[J]. Proceedings of the Chinese Society for Electrical Engineering, 1999, 19(3): 2-6.
[14] 孙万泉, 郑泽知. 基础激励下水电机组轴系统的非线性动力分析[J]. 水力发电学报, 2020, 39(3): 96-105.
SUN Wan-quan, ZHENG Ze-ru. Nonlinear dynamic analysis of hydropower generator shaft system under foundation excitations[J]. Journal of Hydroelectric Engineering, 2020, 39(3): 91-105
[15] 王威, 甘春标. 不确定性激励下碰摩转子的振动响应识别[J]. 振动与冲击, 2019, 38(18): 122-127.
WANG Wei, GAN Chun-biao. Identification of the vibration responses of a rub-impact rotor under uncertain excitation[J]. Journal of Vibration and Shock, 2019, 38(18): 122-127.
[16] 张智勇. 球轴承-转子系统变柔度振动的分岔与滞后行为[D]. 哈尔滨: 哈尔滨工业大学, 2015.
ZHANG Zhi-yong. Bifurcations and hystersis of varying compliance vibrations of a ball bearing-rotor system[D]. Harbin: Harbin Institute of Technology, 2015.
[17] Yamauchi S. The nonlinear vibration of flexible rotors, 1st report, development of a new analysis technique[J]. Transactions of the Japan Society of Mechanical Engineers, Part C ,1983,49(446):1862-1868.
[18] Villa C, Sinou J J, Thouverez F. Stability and vibration analysis of a complex flexible rotor bearing system[J]. Communications in Nonlinear Science and Numerical Smiulation, 2008, 13: 804-821.
[19] Kim Y B, Noah S T. Stability and bifurcation analysis of oscillators with piecewise-linear characteristics: a general approach[J]. ASME Journal of Applied Mechanics, 1991, 58(2): 545-553.
[20] Kim Y B, Noah S T. Steady-state analysis of a nonlinear rotor-housing system[J]. Journal of Engineering for Gas Turbines and Power, 1991, 113(4): 550-556
[21] Zhang Z, Chen Y, Cao Q. Bifurcations and hysteresis of varying compliance vibrations in the primary parametric resonance for a ball bearing[J]. Journal of Sound and Vibration, 2015, 350: 171-184.
[22] Hou L, Chen Y, Fu Y, et al. Application of the HB–AFT method to the primary resonance analysis of a dual-rotor system[J]. Nonlinear Dynamics, 2017, 88(4): 2531-2551.
[23] 李洪亮, 侯磊, 徐海鹏，等. 基于HB-AFT方法的不对中转子系统超谐共振分析[J]. 机械工程学报, 2019, 55(13): 80-86.
LI Hong-liang, HOU Lei, XU Hai-peng, et al. Superharmonic resonance analysis of misaligned rotor system based on HB-AFT method[J]. Journal of Mechanical Engineering, 2019, 55(13): 80-86.
[24] Pei L, Wang S. Dynamics and the periodic solutions of the delayed non-smooth Internet TCP-RED congestion control system via HB-AFT[J]. Applied Mathematics and Computation, 2019, 361: 689-702.
[25] Wang S, Pei L. Periodic solutions and complicated dynamics in network congestion control systems with state-dependent round-trip delays and non-smooth dropping probability[J]. Chaos: An Interdisciplinary Journal of Nonlinear Science, 2020, 30(5): 53105.
[26] Yuan T, Yang J, Chen L. A harmonic balance approach with alternating frequency/time domain progress for piezoelectric mechanical systems[J]. Mechanical Systems and Signal Processing, 2019, 120: 274-289.
[27] Van T J, Alijani F, Voormeeren S N, Lacarbonara W. Frequency domain modeling of nonlinear end stop behavior in Tuned Mass Damper systems under single-harmonic and multi-harmonic excitations[J]. Journal of Sound and Vibration, 2019, 438: 139-152.
[28] 罗忠, 周逸夫, 边子方，等. 滚动轴承非线性因素对转子系统振动特性的影响[J]. 东北大学学报(自然科学版), 2019, 40(8): 1131-1138.
LUO Zhong, ZHOU Yi-fu, BIAN Zi-fang, et al. Influence of Nonlinearity factors of rolling bearings on vibration characteristics of rotor system[J]. Journal of Northeastern University(Natural Science), 2019, 40(8): 1131-1138.
[29] Guo D, Chu F, Chen D. The unbalanced magnetic pull and its effects on vibration in a three-phase generator with eccentric rotor[J]. Journal of Sound and Vibration, 2002, 254(2): 297-312.
[30] Adiletta G, Guido A R , Rossi C. Chaotic Motions of a Rigid Rotor in Short Journal Bearings[J]. Nonlinear Dynamics, 1996, 10(3): 251-269.
[31] 马震岳, 张雷克, 陈婧. 水轮发电机组转子-轴承系统横向振动特性分析[J]. 黑龙江大学工程学报, 2010, 1(4): 17-23.
MA Zhen-yue, ZHANG Lei-ke, CHEN Jing. Lateral Vibration Analysis of Rotor -bearing System for Hydroelectric Set[J]. Journal of Engineering of Heilongjiang University, 2010, 1(4): 17-23.