液膜密封振动及冲击动力学特性

摘要
图/表
参考文献(28)
相关文章 (15)

全文: PDF (1231 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要液膜密封运行过程因工况瞬时变化、系统振动及润滑不足等因素易引发端面接触冲击，严重影响密封寿命。建立考虑端面接触的液膜密封动力学模型，采用直接数值求解方法对运动方程、质量守恒空化边界雷诺方程、微凸体接触方程在全时间域内耦合求解，研究了液膜空化、轴向扰动及运行工况瞬变对密封稳定性与冲击特性的影响。结果表明：液膜空化有效提高了系统抗干扰能力，膜厚越小，受扰动后震荡频率越大且恢复至稳定状态的时间越长；发生端面冲击时膜厚振动频率显著大于全液膜状态下所受扰动情况。随转速及密封腔压力变化值的不断扩大，接触载荷值及冲击频率均不断增大，冲力响应越显著，在端面接触发生瞬间有明显的速度方向突变。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	徐鲁帅1
	郝木明2
	袁小阳1
	王赟磊1
	金英泽1
	李勇凡2

关键词 ：液膜密封, 振动特性, 冲击响应, 稳定性

Abstract：The instantaneous change of operating conditions, system vibration and insufficient lubrication easily cause rub-impact of sealing surface, which has serious effect on the service life of liquid film seals. Dynamic model of sealing system considering face contact was established. Then the equations of motion, Reynolds equation considering mass conservation cavitation boundary condition and asperity contact equation were solved simultaneously at each time step. Furthermore, the effects of liquid film cavitation, axial disturbance and transient operating conditions on seal stability and impact characteristics were investigated. Results show that cavitation dramatically improves the anti-disturbance ability of sealing system. The vibration frequency of liquid film is significantly larger than that of full film lubricated regime when contact occurs. The impact force and shock frequency are continuously enhanced with increase of speed and pressure. There is an obvious change of velocity direction at the instant of face impact.

Key words： liquid film seals, vibration characteristics, impact response, stability

收稿日期: 2019-03-15 出版日期: 2020-07-28

引用本文:

徐鲁帅1，郝木明2，袁小阳1，王赟磊1，金英泽1，李勇凡2. 液膜密封振动及冲击动力学特性[J]. 振动与冲击, 2020, 39(15): 58-65.
XU Lushuai1，HAO Muming2，YUAN Xiaoyang1，WANG Yunlei1，JIN Yingze1，LI Yongfan2. Dynamic analysis for vibration and impact of liquid film sealing. JOURNAL OF VIBRATION AND SHOCK, 2020, 39(15): 58-65.

链接本文:

http://jvs.sjtu.edu.cn/CN/ 或 http://jvs.sjtu.edu.cn/CN/Y2020/V39/I15/58

[1] Lebeck A O. Principles and design of mechanical face seals[M]. New York: John Wiley & Sons Inc. 1991: 463-474.
[2] 郝木明. 机械密封技术及应用[M]. 北京: 中国石化出版社, 2014: 76-87.
[3] 顾永泉. 机械端面密封[M]. 东营: 石油大学出版社, 1994: 90-100.
[4] 宫燃, 葛如海, 谢明祥. 密封环扰动状态下稳定性分析及动态响应[J]. 振动与冲击, 2011, 30(8): 179-182.
GONG Ran, GE Ruhai, XIE Mingxiang. Stability and dynamical characteristic investment on seal under small disturbance[J].Journal of Vibration and Shock, 2011, 30(8): 179-182.
[5] 胡松涛, 黄伟峰, 刘向锋,等. 螺旋槽干气密封压差扰动下的瞬态特性研究[J]. 流体机械, 2017, 45(2): 22-27.
HU Songtao, HUANG Weifeng, LIU Xiangfeng, et al. Transient response analysis of spiral groove gas face seals under pressure-drop fluctuation[J]. Fluid Machinery, 2017, 45(2): 22-27.
[6] ETSION I, GREEN I. Mechanical face seal dynamics[j]. mechanical face seal dynamics, 1985.
[7] MILLER B A, WOODRUFF G W. Numerical formulation for the dynamic analysis of spiral-grooved gas face seals[J]. Journal of Tribology, 2001, 123(2):395-403.
[8] GREEN I, BARNSBY R M. A Simultaneous numerical solution for the lubrication and dynamic stability of noncontacting gas face seals[J]. Journal of Tribology, 2001, 123(2):388-394.
[9] BO R. Numerical modeling of dynamic sealing behaviors of spiral groove gas face seals[J]. Journal of Tribology, 2002, 124(1): 186-195.
[10] BLASIAK S, ZAHORULKO A V. A parametric and dynamic analysis of non-contacting gas face seals with modified surfaces[J]. Tribology International, 2016, 94: 126-137.
[11] MILLER B A, WOODRUFF G W. Numerical formulation for the dynamic analysis of spiral-grooved gas face seals[J]. Journal of Tribology, 2001, 123(2): 395-403.
[12] MILLER B A, GREEN I. Numerical techniques for computing rotor dynamic properties of mechanical gas face seals[J]. Journal of Tribology, 2002, 124(4):1-9.
[13] LIU W, LIU Y, HUANG W, et al. Effect of disturbances on the dynamic performance of a wavy-tilt-dam mechanical seal[J]. Tribology International, 2013, 64(3):63-68.
[14] VARNEY P, GREEN I, et al. Impact phenomena in non-contacting mechanical face seals[J]. Journal of Tribology, 2016, 139(2): 197-231.
[15] HU S , HUANG W , Liu X , et al. Influence analysis of secondary O-ring seals in dynamic behavior of spiral groove gas face seals[J]. Chinese Journal of Mechanical Engineering, 2016, 29(3):507-514.
[16] HUANG W , LIN Y , LIU Y , et al. Face rub-impact monitoring of a dry gas seal using acoustic emission[J]. Tribology Letters, 2013, 52(2):253-259.
[17] ZHAO Y M, YUAN S H, HU J B, et al. Nonlinear dynamic analysis of rotary seal ring considering creep rotation[J]. Tribology International, 2015, 82: 101-109.
[18] 俞树荣, 朱丽, 丁雪兴, 等. 干气密封气膜—密封环系统轴向振动动力稳定性分析[J]. 振动与冲击, 2012, 31(15): 101-104.
YU Shurong, ZHU Li, DING Xuexing, et al. Nonlinear stability analysis on axial vibration of dry gas seals system with gas film and seal rings[J]. Journal of Vibration and Shock, 2012, 31(15): 101-104.
[19] 徐鲁帅, 郝木明, 李勇凡,等. 液膜密封非定常工况下的瞬态特性[J]. 化工学报, 2018, 69(4).
XU Lushuai, HAO Muming, LI Yongfan, et al. Transient characteristics of liquid film seals under unsteady conditions[J]. CIESC Journal 2018, 69(4).
[20] 李勇凡, 郝木明, 孙鑫晖, 等. 动环补偿型液膜密封三自由度动力学响应特性分析[J]. 振动与冲击, 2019, 38(01): 58-65+103.
LI Yongfan, HAO Muming, SUN Xinghui, et al. 3-DOF dynamic response characteristics of rotor compensated liquid film seal[J]. Journal of Vibration and Shock, 2019, 38(01): 58-65+103.
[21] 佘宝瑛. 方向性微孔端面液体密封的理论与试验研究[D]. 浙江工业大学, 2013.
[22] PATIR N, CHENG H S. Application of average flow model to lubrication between rough sliding surfaces[J]. Journal of Tribology, 1979, 101(2): 220.
[23] GU C , MENG X , XIE Y , et al. Mixed lubrication problems in the presence of textures: An efficient solution to the cavitation problem with consideration of roughness effects[J]. Tribology International, 2016, 103:516-528.
[24] WU C, ZHENG L. An average Reynolds equation for partial film lubrication with a contact factor.[J] Tribol 1989; 111: 188–91.
[25] ETSION I, FRONT I. A model for static sealing performance of end face seals[J]. Tribology Transactions, 1994, 37(1): 111-119.
[26] CHANG W R, ETSION I, BOGY D B. An elastic-plastic model for the contact of rough surfaces[J]. Journal of Tribology, 1987, 109(2): 257-263.
[27] BERGMANN P , GRUN, FLORAN, et al. On the modelling of mixed lubrication of conformal contacts[J]. Tribology International, 2018:S0301679X18301555.
[28] 杨文静, 郝木明, 李振涛, 等. 考虑锥度及波度的螺旋槽液膜密封动态特性分析[J]. 化工学报, 2016(12): 293-301.
YANG Wenjing，HAO Muming，LI Zhentao，et al． Analysis
of dynamic characteristics of spiral groove liquid film seal considering taper and waviness[J]． CIESC Journal, 2016, 67(12) : 293-301.