钢弹簧浮置板隔振器垂向动反力随机振动特征研究

摘要
图/表
参考文献(38)
相关文章 (15)

全文: PDF (2498 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要为研究地铁浮置板轨道(FST)钢弹簧隔振器的垂向动反力(DRF)的随机性特征，采用有限元法与虚拟激励法(PEM)，建立了列车-浮置板轨道(T-FST)耦合系统垂向随机振动计算模型。采用多刚体动力学建立列车模型；采用有限元方法建立浮置板轨道有限元模型；基于等效Hertz线性轮轨接触关系建立列车-浮置板轨道耦合系统动力学方程。通过虚拟激励法将非平稳随机振动问题转化为确定性时间历程问题，推导了列车-浮置板轨道耦合时变系统随机振动计算模型。基于该模型，计算研究了钢弹簧隔振器垂向动反力的随机特征。研究表明：钢弹簧隔振器动反力受列车轴重引起的确定性激励控制，轨道不平顺随机激励对钢弹簧隔振器动反力影响较小；不同轨道不平顺对钢弹簧隔振器动反力功率谱主频分布影响不显著；钢弹簧隔振器动反力统计参数随着车速的增大而增大。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	朱志辉
	黄宇佳
	黄承志
	丁德云

关键词 ：浮置板, 车-轨耦合系统, 钢弹簧隔振器, 动反力(DRF), 随机振动, 虚拟激励法(PEM)

Abstract：In order to study the random characteristics of the vertical dynamic reaction force(DRF) of the steel spring isolator on the floating slab track(FST) of a subway, a vertical random vibration model of the train-floating slab track (T-FST) coupling system was established by using the finite element method and the pseudo excitation method (PEM).Multi-rigid body dynamics was used to build the train model; the finite element method was used to establish the floating slab track finite element model; the equivalent Hertz linear wheel-rail contact relationship was used to establish the T-FST coupling system dynamic equation.The non-stationary random vibration problem was transformed into a deterministic time history problem by the PEM, and the calculation model of the random vibration of the T-FST coupled time-varying system was deduced.Based on this model, the random characteristics of the vertical DRF of the steel spring isolator were studied.The results show that the vertical DRF of the steel spring vibration isolator is controlled by the deterministic excitation caused by train axle load, and track irregularity-induced random excitation has little effect on it.Different track irregularities have no effect on the main frequency distribution of the vertical DRF power spectrum of steel spring isolators.The statistical parameters of the vertical DRF of the steel spring isolator increase with the vehicle speed.

Key words： floating slab train-track coupled system steel spring isolator dynamic reaction force(DRF) random vibration pseudo excitation method (PEM)

收稿日期: 2020-02-17 出版日期: 2021-08-28

引用本文:

朱志辉，黄宇佳，黄承志，丁德云. 钢弹簧浮置板隔振器垂向动反力随机振动特征研究[J]. 振动与冲击, 2021, 40(16): 204-212.
ZHU Zhihui,HUANG Yujia,HUANG Chengzhi,DING Deyun. Random characteristics for vertical dynamic reaction force of steel spring isolator in a floating slab. JOURNAL OF VIBRATION AND SHOCK, 2021, 40(16): 204-212.

链接本文:

http://jvs.sjtu.edu.cn/CN/ 或 http://jvs.sjtu.edu.cn/CN/Y2021/V40/I16/204

［1］宋姣姣,练松良,高云锋.弹簧浮置板用隔振器阻尼比的设计取值研究［C］∥第十三届全国振动理论及应用学术会.南京: 中国振动工程学会, 2019.

［2］李永朋.钢弹簧隔振器参数变化对结构谐响应影响的研究［J］.安徽建筑,2019,26(5):83-85.
LI Yongpeng.Research on the structure of the harmonic response on theinfluence of steel spring vibration isolator parameter［J］.Anhui Architecture, 2019,26(5): 83-85.

［3］李永朋.地铁浮置板金属隔振器的性能的试验研究［J］.安徽建筑,2019,26(6):190-191.
LI Yongpeng.Experimental research on the performance of subway floating slab metal isolator ［J］.Anhui Architecture, 2019,26(6):190-191.

［4］王建伟, 蔡成标, 朱胜阳.浮置板轨道钢弹簧隔振器动态特性参数的频率与幅值依赖性试验研究［J］.中国科学: 技术科学, 2016, 46(8): 808-814.
WANG Jianwei, CAI Chengbiao, ZHU Shengyang.Experimental study on frequency and amplitude dependent behavior of dynamic parameters of steel-spring vibration isolator used in floating slab track［J］.Scientia Sinica Technologica, 2016, 46(08): 808-814.

［5］何庆烈, 朱胜阳, 蔡成标, 等.地铁浮置板用钢弹簧隔振器力学特性试验研究［J］.铁道科学与工程学报, 2016, 13(8): 1492-1498.
HE Qinglie, ZHU Shengyang, CAI Chengbiao, et al.Experimental study on mechanical characteristics of the subway-using steel spring vibration isolator［J］.Journal of Railway Science and Engineering, 2016, 13(8): 1492-1498.

［6］何庆烈,王建伟,陈再刚,等.地铁浮置板用隔振器刚度与阻尼试验［J］.西南科技大学学报,2015,30(4):38-41.
HE Qinglie, WANG Jianwei, CHEN Zaigang, et al.Stiffness and damping measurement of vibration isolator used for the metro floating slab［J］.Journal of Southwest University of Science and Technology,2015,30(4):38-41.

［7］农兴中,李祥,刘堂辉,等.浮置板下声子晶体隔振器带隙特性研究［J］.西南交通大学学报,2019,54(6):1203-1209.
NONG Xingzhong, LI Xiang, LIU Tanghui, et al.Band gap characteristics of vibration isolators of phononic crystals under floating slab［J］.Journal of Southwest Jiaotong University,2019,54(6):1203-1209.

［8］刘吉晔.基于几何非线性动力学理论的浮置板隔振器设计研究［D］.哈尔滨: 哈尔滨工业大学, 2019.

［9］张恒.城市轨道交通浮置板用易更换型橡胶隔振器［D］.石家庄: 石家庄铁道大学, 2017.

［10］刘伟栋,廖英英,刘永强.基于GA-PS的轨道橡胶隔振器滞回模型参数识别［J］.石家庄铁道大学学报(自然科学版),2017,30(4):46-51.
LIU Weidong, LIAO Yingying, LIU Yongqiang.Parameter identifying of the rubber damper hysteresis loop based on GA-PS［J］.Joural of Shijiazhuang Tiedao University(Natural Science Edition), 2017,30(4): 46-51.

［11］张波,申伟,张华.浮置板用复合弹簧隔振器的研制［J］.铁道车辆,2016,54(5): 19-22.
ZHANG Bo, SHEN Wei, ZHANG Hua.Development of composite spring isolator for floating slab［J］.Rolling Stock,2016,54(5):19-22.

［12］陈柯龙.基于磁流变技术的地铁短型浮置板轨道隔振器参数优化研究［D］.重庆: 重庆邮电大学, 2012.

［13］赵纣斌.几种典型的地铁减振浮置轨道的对比分析［J］.都市快轨交通,2018,31(2):102-107.
ZHAO Zhoubin.Comparative analyses of several typical metro vibration damping floating tracks［J］.Urban Rapid Rail Transit,2018,31(2): 102-107.

［14］邱纪侠,喻敏英.宁波地铁2号线钢弹簧浮置板轨道的减振效果对比分析［J］.价值工程,2018,37(24):127-129.
QIU Jixia, YU Minying.Comparative analysis of vibration reduction effect of steel spring floating slab track in Ningbo subway line 2［J］.Value Engineering,2018,37(24):127-129.

［15］余关仁,沈景凤,陈侃,等.轨道支撑失效对钢弹簧浮置板动力响应特性的影响［J］.噪声与振动控制,2015,35(6):78-81.
YU Guanren, CHEN Jingfeng, CHEN Kan, et al.Influence of railway-support failure on the dynamic response characteristics of steel spring floating slab track［J］.Noise and Vibration Control, 2015,35(6):78-81.

［16］梁上燕,肖安鑫,耿传智.阻尼钢弹簧浮置板轨道结构隔振性能分析［J］.噪声与振动控制,2013,33(1):136-139.
LIANG Shangyan, XIAO Anxin, GENG Chuanzhi.Analysis of vibration isolation performance of floating slab track structure with damping steel springs［J］.Noise and Vibration Control,2013,33(1): 136-139.

［17］李忠继, 林红松, 颜华, 等.连续型浮置板轨道隔振器疲劳载荷谱研究［J］.铁道工程学报, 2016,33 (12): 53-58.
LI Zhongji, LIN Hongsong, YAN Hua, et al.Research on the load spectrums of isolator of the continuous floating slab track［J］.Journal of Railway Engineering Society, 2016, 33(12): 53-58.

［18］李俊岭, 徐鹏, 翟婉明, 等.钢弹簧浮置板轨道支点力动力特性分析［J］.铁道建筑, 2011 (1): 106-109.
LI Junling, XU Peng, ZHAI Wanming, et al.Dynamic performance analysis of track’s fulcrum pressures transferring to steel spring floating slab［J］.Railway Engineering, 2011(1): 106-109.

［19］方联民, 朱志辉, 王力东, 等.车致“站桥合一”高速铁路客站随机振动分析［J］.铁道学报, 2017, 39(9): 117-125.
FANG Lianmin, ZHU Zhihui, WANG Lidong, et al.Analysis of train induced random vibration of high-speed railway station with "integral station-bridge structure”［J］.Journal of the China Railway Society, 2017, 39(9): 117-125.

［20］赵岩, 张亚辉, 林家浩.车辆随机振动功率谱分析的虚拟激励法概述［J］.应用数学和力学, 2013, 34(2): 107-117.
ZHAO Yan, ZHANG Yahui, LIN Jiahao.Summary on the pseudo-excitation method for vehicle random vibration PSD analysis［J］.Applied Mathematics and Mechanics, 2013, 34(2): 107-117.

［21］王贵春, 潘家英.轨道不平顺导致的车桥耦合振动分析［J］.铁道工程学报, 2006(8): 30-33.
WANG Guichun, PAN Jiaying.Analysis of vehicle-bridge coupled vibration due to track irregularities［J］.Journal of Railway Engineering Society, 2006(8): 30-33.

［22］夏禾.车辆与结构动力相互作用［M］.北京: 科学出版社, 2002.

［23］LU F, LIN J H, KENNEDY D, et al.An algorithm to study non-stationary random vibrations of vehicle-bridge systems［J］.Computers & Structures, 2009, 87(3/4): 177-185.

［24］夏禾, 张宏杰, 曹艳梅, 等.车桥耦合系统在随机激励下的动力分析及其应用［J］.工程力学, 2003, 20(3): 142-149.
XIA He, ZHANG Hongjie, CAO Yanmei, et al.Dynamic analysis of train-bridge system under random excitations［J］.Engineering Mechanics, 2003, 20(3): 142-149.

［25］晋智斌, 强士中, 李小珍.轨道不平顺激励下车辆-桥梁垂向随机振动方差解法［J］.铁道学报, 2008, 30(6): 63-68.
JIN Zhibin, QIANG Shizhong, LI Xiaozhen.Covariance method for vehicle-bridge vertical stochastic vibration excited by rail irregularities［J］.Journal of the China Railway Society, 2008, 30(6): 63-68.

［26］方同, 冷小磊, 李军强, 等.演变随机响应问题的统一解法［J］.振动工程学报, 2002, 15(3): 290-294.
FANG Tong, LENG Xiaolei, LI Junqiang, et al.A unified approach to evolutionary random response problem［J］.Journal of Vibration Engineering, 2002, 15(3): 290-294.

［27］ZHU Y, LI X Z, JIN Z B.Three-dimensional random vibrations of a high-speed-train-bridge time-varying system with track irregularities［J］.Proceedings of the Institution of Mechanical Engineers, Part F: Journal of Rail & Rapid Transit, 2016, 230(8): 1851-1876.

［28］JIE L, CHEN J B.Probability density evolution equations: a historical investigation［J］.Journal of Earthquake & Tsunami, 2009, 3(3): 209-226.

［29］李小珍, 雷虎军, 朱艳.车-轨-桥动力系统中Rayleigh阻尼参数分析［J］.振动与冲击, 2013, 32(21): 52-57.
LI Xiaozhen, LEI Hujun, ZHU Yan.Analysis of rayleigh damping parameters in a dynamic system of vehicle-track-bridge［J］.Journal of Vibration and Shock, 2013, 32(21): 52-57.

［30］XU Q Y, YAN B, LOU P, et al.Influence of slab length on dynamic characteristics of subway train-steel spring floating slab track-tunnel coupled system［J］.Latin American Journal of Solids and Structures, 2015, 12(4): 649-674.

［31］石蕊,张晓芸,石广田,等.钢弹簧浮置板中低频振动特性分析［J］.噪声与振动控制,2019,39(1):131-135.
SHI Rui, ZHANG Xiaoyun, SHI Guangtian, et al.Analysis of vibration characteristics of steel spring floating slabs in low and middle frequency ranges［J］.Noise and Vibration Control,2019,39(1):131-135.

［32］米洋.城市轨道交通钢弹簧浮置板轨道过渡段设置方法研究［D］.兰州: 兰州交通大学, 2016.

［33］金皖锋.地铁列车引起的地基振动及浮置板减振研究［D］: 浙江大学, 2013.

［34］单涛涛,楼梦麟,贾宝印.关于上海地铁一号线轨道高低不平顺问题的探讨［J］.振动与冲击,2012,31(12):53-58.
SHAN Taotao, LOU Menglin, JIA Baoyin.Preliminarily exploring a problem of track vertical profile irregularity of Shanghai metro line 1［J］.Journal of Vibration and Shock,2012,31(12):53-58.

［35］XU Q Y, OU X, AU F T K, et al.Effects of track irregularities on environmental vibration caused by underground railway［J］.European Journal of Mechanics-A/Solids, 2016, 59: 280-293.

［36］朱志辉, 黄承志, 王力东, 等.基于车-桥随机振动模型的简支梁桥墩顶垂向动反力特征研究［J］.振动与冲击, 2018, 37(15) : 225-232.
ZHU Zhihui, HUANG Chengzhi, WANG Lidong, et al.Random characteristics for vertical dynamic reaction force of pier-top of a simply supported girder bridge based on train-bridge random vibration model［J］.Journal of Vibration and Shock, 2018, 37(15): 225-232.

［37］MA L X, LIU W M.A numerical train-floating slab track coupling model based on the periodic-Fourier-modal method［J］.Proceedings of the Institution of Mechanical Engineers Part F: Journal of Rail and Rapid Transit,2018,232(1):315-334.

［38］XU Q Y, XIAO Z C, LIU T, et al.Comparison of 2D and 3D prediction models for environmental vibration induced by underground railway with two types of tracks［J］.Computers and Geotechnics,2015,68:169-183.