基于地面共振试验的操纵面间隙非线性颤振分析方法

摘要
图/表
参考文献(17)
相关文章 (15)

全文: PDF (1455 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要以某型民机带中心对称间隙的方向舵为研究对象，按动力相似准则设计了尾翼颤振风洞模型，通过地面共振试验获得不同操纵刚度和自由间隙组合情况下方向舵旋转模态的力频曲线，根据收敛的频率值获得有限元模型作动器单元的等效刚度，经动力学特性修正后的有限元模型进行了颤振分析，风洞试验后通过比较表明，计算结果与试验结果吻合：（1）颤振速度一致；（2）颤振频率的偏差不大于6.5%；（3）颤振型一致。由此可见，根据试验频率得到的等效操纵刚度是准确的，用来预测弹性操纵面的极限环振荡临界速度是可行的，可以作为民机适航符合性验证的一种手段。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	陈文
	窦忠谦
	何俊
	章俊杰

关键词 ：地面共振试验, 操纵面, 间隙, 非线性, 颤振, 适航验证

Abstract：A rudder with central symmetric freeplay of a civil transport airplane is investigated. A tail flutter wind tunnel model is designed according to the dynamic similarity criterion. The force-frequency curves of rudder rotational modes in various combination of control stiffness and freeplay are achieved by ground vibration test. The equivalent stiffness of actuator element of finite element model is achieved according to the convergent frequencies. The flutter analysis is carried out based on dynamical updating finite element model. The numerical results are in good agreement with the test data. (1) The calculated flutter speed is close to the test data. (2) The difference of flutter frequencies between simulation and test are less than 6.5%. (3) The flutter modes are the same between simulation and test. The validated equivalent control stiffness achieved by test frequencies can be used to predict the LCO critical velocity of elastic control surface. The method can also be proof of compliance for airworthiness standards.

Key words： ground vibration test control surface freeplay nonlinearity flutter airworthiness

收稿日期: 2018-12-25 出版日期: 2020-08-15

引用本文:

陈文，窦忠谦，何俊，章俊杰. 基于地面共振试验的操纵面间隙非线性颤振分析方法[J]. 振动与冲击, 2020, 39(16): 75-80.
CHEN Wen，DOU Zhongqian，HE Jun，ZHANG Junjie. A numerical method based on ground vibration test for flutter analysis of the control surface with freeplay nonlinearity. JOURNAL OF VIBRATION AND SHOCK, 2020, 39(16): 75-80.

链接本文:

http://jvs.sjtu.edu.cn/CN/ 或 http://jvs.sjtu.edu.cn/CN/Y2020/V39/I16/75

[1] 杨智春，田玮，谷迎松，贺顺. 带集中非线性的机翼气动弹性问题研究进展[J]. 航空学报，2016，37(7): 2013-2044.
YANG Zhichun, TIAN Wei, GU Yingsong, HE Shun. Advance in the study on wing aeroelasticity with concerntrated nonlinearity[J]. ACTA Aeronautica et Astronautica Sinica, 2016, 37(7): 2013-2044.
[2] 李毅，杨智春，金伟. 操纵面非线性气动弹性响应引起的结构疲劳损伤分析方法研究[J]. 振动与冲击，2015, 34(11): 41-45.
LI Yi, YANG Zhichun, JIN Wei. Analysis method of structural fatigue damage induced by nonlinear aeroelastic response of control surface[J]. Journal of Vibration and Shock, 2015, 34(11): 41-45.
[3] 军用飞机结构强度规范第7部分：气动弹性GJB 67.7A—2008 [M]. 2008：4-5.
[4] 中国民用航空总局.中国民用航空规章第25部运输类飞机适航标准[M]. 2005, 68-69.
[5] 飞机设计手册（第9册，载荷、强度和刚度）[M]. 航空工业出版社，2001：1161.
[6] 陈衍茂，刘济科，孟光. 二元机翼非线性颤振系统的若干分析方法[J]. 振动与冲击，2011, 30(3): 129-134.
CHEN Yanmao, LIU Jike, MENG Guang. Analysis methods for nonlinear flutter of a two-dimensional airfoil: a review[J]. Journal of Vibration and Shock, 2011, 30(3): 129-134.
[7] NI K，HU P，ZHAO H W. Flutter and LCO of an all-movable horizontal tail with freeplay[C]//Proceedings of 53rd AIAA/ASME/ASCE/AHS/ASCE/ASC Structures, structural Dynamics and Meterials Conference.[S.I.]: Springer International Publishing, 2012: 1-9.
[8] HU P，ZHAO H W，XUE L P. High-fidelity modeling and simulation of flutter/LCO for all-movable horizontal tail with freeplay[C] //Proceedings of AIAA Atmospheric Flight Mechanics Conference. Reston: AIAA, 2011: 1-13.
[9] SHEN S F. An approximate Analysis of Nonlinear Flutter Problems[J]. Journal of the Aerospace Sciences, 1959, 26: 25-31.
[10] Samuel C.，Robert E. Reed Jr.，William P. Rodden. Experimental and Theoretical Study of Nonlinear Flutter[J]. AIAA 80-0791R, 1981, 18(12): 1057-1063.
[11] YANG Zhichun，ZHAO Lingcheng. Analysis of Limit Cycle Flutter of An Airfoil in Incompressible Flow[J]. Journal of Sound and Vibration, 1988, 123(1): 1-13.
[12] Robert N. Desmarais，Wilmer H. Reed. Wing/Store Flutter with Nonlinear Pylon Stiffness[J]. AIAA 80-0792R, 1981, 18(11): 984-987.
[13] 杨翎仁，赵令诚. 带外挂三角机翼极限环颤振的实验研究[J]. 应用力学学报，1991, 8(3): 38-44.
YANG Yiren, ZHAO Lingcheng. Experimental Study of Limit Cycle Flutter of a Delta Wing Model with External Store[J]. Chinese Journal of Applied Mechanics, 1991, 8(3): 38-44.
[14] 尹磊磊，张思进，文桂林，徐慧东. 间隙约束二元翼段系统分岔与多解共存现象分析[J]. 航空动力学报，2014，29(6): 1410-1416.
YIN Leilei, ZHANG Sijin, WEN Guilin, XU Huidong. Analysis on the system bifurcation and coexistence of multiple solutions for typical airfoil section with freeplay[J]. Journal of Aerospace Power, 2014，29(6): 1410-1416.
[15] 陈识，李秋彦，冉玉国. 具有二维间隙非线性的全动舵面动力特性研究[J]. 四川理工学院学报，2017，30(1): 60-64.
CHEN Shi, LI Qiuyan, RAN Yuguo. All-movable control surface dynamical characteristic research with 2-d freeplay non-linearity[J]. Journal of Sichuan University of Science & Engineering, 2017，30(1): 60-64.
[16] 管德.飞机气动弹性力学手册[M]. 北京：航空工业出版社，1993：186-187.
[17] 赵永辉.气动弹性力学与控制[M]. 北京：科学出版社，2007：37-59.