大型地下厂房开挖爆破损伤影响范围及评价研究

PDF(1461 KB)

振动与冲击 ›› 2015, Vol. 34 ›› Issue (23) : 54-61.

论文

陈俊桦 1，张家生1，李新平2

作者信息 +

Study of rock blasting-induced damage zone and its evaluation under excavation of large-scale underground powerhouse

CHEN Jun-hua1，ZHANG jia-sheng1，LI Xin-ping2,

Author information +

文章历史 +

摘要

针对溪洛渡主厂房浅孔台阶开挖爆破工程，根据C-J爆轰理论和强度统计理论等分别得到炮孔壁上爆炸冲击荷载曲线和考虑压、拉损伤的岩石动力损伤本构关系。在FLAC3D数值软件中应用该爆炸荷载曲线和本构关系，并建立模拟单个垂直炮孔起爆的三维有限差分计算模型，分析岩石爆破动力响应，得到爆破损伤影响范围特性。同时在现场进行了爆破试验、钻孔声波测试和爆破振动速度测试。将现场试验、基于TCK体积拉伸损伤模型的数值计算与考虑压、拉损伤的数值计算的结果对比，验证压、拉损伤数值模型的合理性。研究成果表明，受地表自由面影响，岩石爆破损伤影响范围随深度增加而减小。炮孔顶部损伤影响水平半径最大，且该半径随单孔炸药量增大而显著增大；与最大损伤影响半径对应的水平径向质点峰值振动速度可作为爆破损伤安全判据；相对深度方向，水平径向为爆破损伤的主要扩展方向；数值计算结果较为合理，研究成果可为类似开挖爆破工程提供参考。

Abstract

Against the background of short-hole bench blasting excavation of the main powerhouse in Xi Loudu hydroelectric power plant, the curve of load on blasthole and the constitutive relation model of rock dynamic damage on account of both compression fracture and tensile damage were suggested according to C-J donation mechanism and the statistical theory of strength. The curve of load and the constitutive relation were applied to software FLAC3D for the establishment of three-dimensional finite difference numerical simulation of single-hole blasting. The characteristics of rock blasting-induced damage zone were obtained through analysis of dynamic responses. Meanwhile, blasting test, test of acoustic wave velocity in borehole and blasting vibration test were carried out on site. The comparison of results obtained from field test, the numerical simulation based on TCK constitutive relation model and the numerical simulation on account of both compression fracture and tensile damage were also made in order to verify the rationality of the one suggested by authors. The results show that, the rock blasting-induce zone expands with the excavation depth decrease because of free surface of ground of excavtion layer. The horizontal radius of blasting-induced zone reaches its maximu on the surface of excavtion layer, at the top of blasthole, and that value increases significantly with the increment of single-hole charge amount. The peak value of horizontal-radicl vibration velocity occuring at the damage margin, on the surface of excavtion layer, can be used as the criterion of blasting-induced damage. The main blasting-induced damage extension is along horizontal-radial direction instead of vertical depth. The numerical results are reasonable and achievement can provide references to the similar blasting excavation projects.

导出引用

陈俊桦 1，张家生1，李新平2. 大型地下厂房开挖爆破损伤影响范围及评价研究[J]. 振动与冲击, 2015, 34(23): 54-61

CHEN Jun-hua1，ZHANG jia-sheng1，LI Xin-ping2,. Study of rock blasting-induced damage zone and its evaluation under excavation of large-scale underground powerhouse[J]. Journal of Vibration and Shock, 2015, 34(23): 54-61

参考文献

[1] 王志亮, 郑明新. 基于TCK损伤本构的岩石爆破效应数值模拟[J]. 岩土力学, 2008, 29(1): 230－234.
WANG Zhi-liang, ZHENG Ming-xin. Numerical simulation of effect of rock blasting based on TCK damage constitutive model[J]. Rock and Soil Mechanics, 2008, 29(1): 230－234.
[2] 杨小林, 王树仁. 岩石爆破损伤模型及评述[J]. 工程爆破, 1999, 5(3): 71－75.
YANG Xiao-lin, WANG Shu-ren. Rock blast damage models and comments[J]. Engineering Blasting, 1999, 5(3): 71－75.
[3] 夏祥, 李俊如, 李海波, 等. 广东岭澳核电站爆破开挖岩体损伤特征研究[J]. 岩石力学与工程学报, 2007, 26(12): 2510－2516.
XIA Xiang, LI Jun-ru, LI Hai-bo, et al. Study of damagecharacteristics of rock mass under blasting load inLing’ao nuclear power station, Guangdong province[J].Chinese Journal of Rock Mechanics and Engineering, 2007, 26(12): 2510－2516.
[4] 张国华，陈礼彪，夏祥, 等. 大断面隧道爆破开挖围岩损伤范围试验研究及数值计算[J].岩石力学与工程学报, 2009, 28(8): 1611－1619.
ZHANG Guohua, CHEN Libiao，XIA xiang et al. Numerical simulation and experimental study of damage range of surrounding rock in large tunnel under blasting excavation[J]. Chinese Journal of Rock Mechanics and Engineering, 2009, 28(8): 1611－1619.
[5] 夏祥. 爆炸荷载作用下岩体损伤特征及安全阈值研究[博士学位论文][D]，中国科学院研究生院博士学位论文，2006.
XIA Xiang. Study on damage characteristics and safety threshold of rock vibration by blast[Ph. D. Thesis][D]. Wuhan：Institute of Rock and Soil Mechanics，Chinese Academy of Sciences，2006.
[6] 李新平，陈俊桦，李友华, 等. 溪洛渡电站地下厂房爆破损伤范围及判据研究[J]. 岩石力学与工程学报，2010，29(10)：2042－2048.
LI Xingpin，CHEN Junhua，LI Youhua. et al. study of criterion and damage zone induced by excavation blasting of underground power-house of Xiluodu hydropower station[J]. Chinese Journal of Rock Mechanics and Engineering, 2010，29(10)：2042－2048.
[7] 左双英, 肖明, 续建科, 等. 隧道爆破开挖围岩动力损伤效应数值模拟[J]. 岩土力学, 2011, 32(10): 3171－3176.
ZUO Shuang-ying, XIAO Ming, XU Jian-ke, et al.Numerical simulation of dynamic damage effect ofsurrounding rocks for tunnels by blasting excavation[J]. Rock and Soil Mechanics, 2011, 32(10): 3171－3176.
[8] 胡英国，卢文波，陈明, 等. 岩石爆破损伤模型的比选与改进[J]. 岩土力学, 2012, 33(11):3278－3284.
HU Yingguo, LU Wenbo, CHEN Ming, et al. Comparison and improvement of blasting damage models for rock[J]. Rock and Soil Mechanics, 2012, 33(11):3278－3284.
[9] Ahrens T J, Rubin A M. Impact-induced tensional failure in rock[J]. Journal of Geophysical Research, 1993, 98(E1):1185-1203.
[10] 朱传云,喻胜春. 爆破引起岩体损伤的判别方法研究[J]. 工程爆破，2001，7(1)，12－16.
ZHU Chuangyun, YU Shengchun. Study on the criterion of rockmass damage caused by blasting[J]. Engineering blasting，2001，7(1)：12－16.
[11] Bauer A, Calder P N. Open pit and blast seminar[D]. Kingston: Mining Engineering Department, Queens University, 1978.
[12] Savely J P. Designing a final blast to improve stability[A]. Presented at the SME Annual Meeting[C]. New Orleans: [s.n.], 1986.
[13] 张文煊, 卢文波. 龙滩水电站地下厂房开挖爆破损伤范围评价[J]. 工程爆破，2008，14(2)：1-7.
ZhANG Wenxuan, LU Wenbo. Evaluation of blast-induced damage zone in excavation blasting of longtan underground workshop[J]. Engineering blasting，2008，14(2)：1–7.
[14] 严鹏，卢文波，单治钢等.深埋隧洞爆破开挖损伤区检测及特性研究[J]. 岩石力学与工程学报, 2009, 28(8): 1552－1561.
YAN Peng, LU Wenbo, SHAN Zhigang. et al.Detecting and study of blasting excavtion-induced damage of deep tunnel and its characters[J]. Chinese Journal of Rock Mechanics and Engineering, 2009,28(8):1552－1561.
[15] 曾新华. 岩石爆破损伤影响范围研究[硕士学位论文][D].天津：天津大学建筑工程学院, 2003.
ZENG Xinhua. Study on the Blast-induced Damage Zone for Rock Excavation[master degree thesis][D]. Tianjin：Tianjin University. School of Civil Engineering, 2003.
[16] 姚强,杨兴国,陈兴泽,等.大型地下厂房开挖爆破振动动力响应数值模拟[J].振动与冲击,2014 ,33(6):66-70.
YAO Qiang,YANG Xing-guo,CHEN Xing-ze,et al.Numerical simulation of dynamic response of large underground powerhouse subjected to blasting vibration[J].Journal of Vibration and Shock,2014,33(6):66-70.
[17] Grady D E, Kipp M E.Continuum modelling of explosive fracture in oil shale[J]. International Journal of Rock Mechanics and Mining Sciences, 1980, (17): 147－157.
[18] Kipp M E, Grady D E. Numerical studies of rock fragmentation[J]. Computers & Chemical Engineering, 1980, 721－735.
[19] Taylor L M, Kuszmaul J S, Ghen E P. Damage accumulation due to macrocracking in brittle rock under dynamic loading[J]. American Society of Mechanical Engineers.1985,(69):95－104.
[20] Chen E P, Taylor L M. Fracture of brittle rock under dynamic loading condition[J]. Fracture Mechanics of Ceramics, 1986, (7) 175－86
[21] Krajcinovic D, Silva M A G. Statistical aspects of the continuous damage theory[J].Int J Solids Structures, 1982, 18(7): 551－562.
[22] 徐卫亚，韦立德.岩石损伤统计本构模型的研究[J].岩石力学与工程学报，2002，21(6)：787–791.
XU Weiya，WEI Lide. Study on tatistical damage constitutive model of rock[J]. Chinese Journal of Rock Mechanics and Engineering, 2002，21(6)：787－791.
[23] 唐春安，徐小荷.岩石全应力一应变过程的统计损伤理论分析[J].东北工学院院报，1987，51（2）：191－195.
TANG Chunan，XU Xiaohe. Statistical Damage Analysis of the Rock Complete Stress-Strain Proeess[J]. Journal of Northeast University of Technology, 1987，51(2)：191－195.
[24] 曹文贵，赵衡，张玲等.考虑损伤阀值影响的岩石损伤统计软化本构模型及其参数确定方法[J].岩石力学与工程学报，2008，27(6):1149－1154.
CAO Wengui，ZHAO Heng，ZHANG ling. et al. damage statistical softenning constitutive model for rock considering effect of damage threshold and its parameters determination method[J]. Chinese Journal of Rock Mechanics and Engineering, 2008，27(6):1149－1154.