含裂纹离心压缩机叶轮结构的振动局部化

PDF(1530 KB)

振动与冲击 ›› 2017, Vol. 36 ›› Issue (6) : 108-113.

论文

含裂纹离心压缩机叶轮结构的振动局部化

王帅，訾艳阳，何正嘉

作者信息 +

Vibration localization of cracked impellers of centrifugal compressors

WANG Shuai,ZI Yanyang,HE Zhengjia

Author information +

文章历史 +

摘要

针对离心压缩机在复杂运行工况下的失谐与裂纹问题，研究裂纹与失谐对叶轮结构振动响应和振动局部化的影响规律。首先，采用三维有限元模型建立具有复杂几何形状的叶轮结构的定量分析模型，并通过在裂纹界面上定义接触的形式模拟裂纹的呼吸效应。其次，通过采用混合界面模态综合法对系统自由度进行缩减，以解决了采用三维有限元模型分析非线性系统动态响应时所存在的计算量大和收敛困难的问题。最终，采用Monte Carlo方法对含裂纹的失谐叶轮结构进行统计分析，研究随机失谐和裂纹故障对叶轮结构振动局部化的影响规律。结果表明裂纹和失谐都会对结构的振动响应产生显著的影响，并会导致振动能量的集中和振动局部化现象。

Abstract

With regard to the mistuning and crack problems of centrifugal impellers operating under complex conditions, the effects of crack and mistuning on the forced response and vibration localization of centrifugal impellers were investigated.3D finite element models of impellers were established for the dynamic analysis of complex impellers.Several contact pairs were defined on the crack surfaces to simulate the nonlinear crack breathing effects.Then,the hybrid interface component mode synthesis method was employed to reduce the number of degrees of freedom of the system.The method can reply the chanllenges of huge computation requirment and convergence in the dynamic response computation of nonlinear system by using directly 3D finite element models.The Monte Carlo method was employed to statistically study the effects of random mistuning and crack fault on the vibration localization of impellers.The results show that both the crack and mistuning will significantly affect the dynamic response of impellers and will lead to the localization of energy on certain blades.

导出引用

王帅，訾艳阳，何正嘉. 含裂纹离心压缩机叶轮结构的振动局部化[J]. 振动与冲击, 2017, 36(6): 108-113

WANG Shuai,ZI Yanyang,HE Zhengjia. Vibration localization of cracked impellers of centrifugal compressors[J]. Journal of Vibration and Shock, 2017, 36(6): 108-113

参考文献

[1] 赵问银, 张家忠, 周成武.大型离心叶轮振动模态局部化特性研究[J].应用力学学报, 2012, 29(6)：699-704.
ZHAO Wenyin,ZHANG Jiazhong,ZHOU Chengwu. Study on the vibration localization in the centrifugal Impeller with periodic structures[J]. Chinese Journal of Applied Mechanics, 2012, 29(6)：669-704.
[2] KUSHNER F, RICHARD S J, STRICKLAND R A. Critical review of compressor impeller vibration parameters for failure prevention[C]. Proceedings of the Twenty-Ninth Turbomachinery Symposium, 2000：103-112.
[3] 白斌, 白广忱, 童晓晨, 等. 整体叶盘结构失谐振动的国内外研究状况[J].航空动力学报, 2014, 29(1)：91-103.
BAI Bin, BAI Guangchen, TONG Xiaochen, et al. Research on vibration problem of integral mistuned bladed disk assemblies at home and aboard[J]. Journal of Aerospace Power, 2014, 29(1)：91-103.
[4] SAITO A, CASTANIER M P, PIERRE C. Effects of a Cracked Blade on Mistuned Turbine Engine Rotor Vibration[J]. Journal of Vibration and Acoustics, 2009, 131(061006)：1-9.
[5] 赵志彬, 贺尔铭, 王红建. 叶盘振动失谐敏感性与频率转向特性内在关系研究[J]. 机械科学与技术, 2010, 29(12)：1606-1611.
ZHAO Zhibin, HE Erming, WANG Hongjian. Correlation Between Frequency Veering and Vibration Mistuning Sensitivity of a Bladed Disk[J]. Mechanical Science and Technology for Aerospace Engineering, 2010, 29(12)：1606-1611.
[6] JUNG C, SAITO A, EPUREANU B I. Detection of Cracks in Mistuned Bladed Disks Using Reduced-Order Models and Vibration Data[J]. Journal of Vibration and Acoustics, 2012, 134(061010)：1-10.
[7] 王艾伦, 李帅. 含呼吸式裂纹的失谐叶盘系统响应特性研究[J]. 中国机械工程, 2013, 24(2)：169-174.
WANG Ailun, LI Shuai. Forced Response Characteristics of Mistuned Bladed Disk with Breathing Crack[J]. Chinese Journal of Mechanical Engineering, 2013, 24(2)：169-174.
[8] SINGH M P, THAKUR B K, SULLIVAN W E, et al. Resonance Identification for Impellers[C]. Proceedings of the Thirty-Second Turbomachinery Symposium, 2003：59-70.
[9] 孟继纲, 王跃方, 杨树华. 离心压缩机闭式叶轮晶粒黏着失谐动力特性研究[J]. 风机技术, 2010：7-12.
MENG Jigang, WANG Yuefang, YANG Shuhua. Research on Dynamic Characteristics of Mistuned Shrouded Impeller with Salt Crystallization in Centrifugal Compressor[J]. Compressor, Blower & Fan Technology, 2010：7-12.
[10] 陈睿, 刘新灵, 蔡显新, 等. 离心叶轮叶片裂纹产生原因分析[J]. 理化检验(物理分册), 2011, 47：60-63.
CHEN Rui, LIU Xinling CAI Xianxin, at al. Reason Analysis on Cracks in Centrifugal Wheel Blade[J]. Physical Testing and Chemical Analysis(Part A:Physical Testing), 2011, 47：60-63.
[11] POUDOU O, PIERRE C. Hybrid frequency-time domain methods for the analysis of complex structural systems with dry friction damping[C]. Structural Dynamics and Materials Conference, Norfolk, VA, USA, 2003：111-124.