为研究电机架悬参数对转向架动力学性能的影响，建立了等效到单轮对的2自由度横向简化模型和8自由度单转向架横向动力学模型，分析了在轮对横向激振下、在不同电机悬挂参数下，构架横移和电机相对构架横移的变化规律，最后研究了电机架悬参数对转向架稳定性的影响。计算结果表明：当电机横移频率接近且略小于转向架蛇行频率时，构架横移最小，线性临界速度最大，但是此时电机相对构架横移很大，此时电机相当于一个动力吸振器，把构架的振动转移到电机上来。电机横移阻尼比越小，构架横移越小，线性临界速度越高，但是电机相对构架横移越大。为了兼顾两者，电机横移阻尼可以把适当取大一点。
Abstract
In order to study the influence of the motor suspension parameters on the dynamic performance of the bogie, the two-degree-of-freedom lateral simplified model and eight-degree-of-freedom lateral bogie model were established, and change of lateral displacement of the frame and the motor relative to the frame and its law were analyzed.Finally, the influence of suspension parameters of the motor on the stability of the bogie was studied.The calculation results show that when the lateral frequency of the motor was close to and slightly smaller than the hunting frequency of the bogie, the lateral displacement of the frame was the smallest, but that of motor relative to the frame is very large. Under this case, the motor is equivalent to a power absorber, the vibration of the frame is transferred to the motor.The smaller the lateral damping ratio of the motor, the smaller the lateral displacement of the frame, the higher the linear critical velocity, the larger the lateral displacement of the motor relative to the frame.In order to take into account both, an appropriate bigger lateral damping ratio is a good choice.
关键词
电机架悬参数 /
动力响应 /
稳定性 /
线性临界速度
{{custom_keyword}} /
Key words
motor bogie-suspended parameters /
dynamic response /
stability /
linear critical velocity
{{custom_keyword}} /
{{custom_sec.title}}
{{custom_sec.title}}
{{custom_sec.content}}
参考文献
[1] 金鼎昌，罗赟，黄志辉. 牵引电机悬挂方式对机车或者动车动力学性能的影响[J]. 铁道学报，1994（6），16(增刊)：43-47.
Jin DC，Luo Y and Huang ZH. The effect of the driving motor’s suspension type on the railway vehicle dynamics[J]. Journal of the China railway society 1994（6）， 16（Sup）: 43–47
[2] 张卫华. 动车组总体与转向架 [M] .北京：中国铁道出版社，2011:202-203.
[3] MIDDENGORF E. 德国铁路公司新一代电机机车[J]. 电机牵引快报，1997,19（3）：1-11.
MIDDENGORF E. The New Electric Locomotive,Generation for DB AG[J].Electric Traction Journal,1997,19(3):1-11
[4] H.HODI A.HAIGERMOSER.高速机车现代化转向架设计的发展[J].电力牵引快报，1995,17（8）：69-77.
H.HODI A.HAIGERMOSER.Development of New Motor Bogie Concept for High Performance Locomotives[J]. Electric Traction Journal, 1995,17(8)：69-77.
[5] 罗赟，金鼎昌. 架悬机车驱动装置悬挂参数规律的研究[J]. 中国铁道科学，2007（7），28（4）:36-42.
LUO Yun, JIN Dingchang. Research on the Rules of Suspension Parameters to Driving Equipments Suspended inBogie Frames[J]. China Railway Science, 2007, 28(4):36-42.
[6] 马卫华，罗世辉，宋荣荣. 提速架悬机车动力学性能的改进[J]. 西南交通大学学报，2007（2）,42（1）：84-88.
MA Weihua，LUO Shihui，SONG Rongrong. Improvement of Dynamic Performance of Speed-Raising Locomotive with Motor Mounted on Frame[J]. Journal of Southwest Jiaotong University，2007（2），42（1）：84-88.
[7] Caihong Huang，Jing Zeng，ShuLin Liang. Influence of system parameters on the stability limit of the undisturbed motion of a motor bogie[J] .Journal of Rail and Rapid Transit, 2014,228(5):522-534.
[8] S.Alfi, L.Mazzola, S.Bruni. Effect of motor connection on the critical speed of high-speed railway vehicles[J]. Vehicle System Dynamics, 2008,46: 201-214.
[9] 姚远，罗世辉，张红军.驱动系统弹性架悬对机车动力学性能影响机理[J].振动工程学报，2012,25（5）：481-487.
YAO Yuan，LUO Shihui，ZHANG Hongjun. TheDynamic Effect Mechanism of Driving System Elastically Mounted on the Bogie Frame to Locomotive[J].Journal of Vibartion Engineering，2012,25（5）：481-487.
[10] 姚远，张开林，张红军，罗世辉.机车驱动系统弹性架悬的机理与应用研究[J].铁道学报，2013,35（4）：23-28.
YAO Yuan，ZHANG Kailin, ZHANG Hongjun, LUO Shihui.Mechanism of Drive System Elastic Suspension and Its Application[J]. Journal of the China railway society，2013,35（4）：23-28.
[11] Utz von Wagner. Nonlinear Dynamic Behaviour of a Railway Wheelset[J].Vehicle System Dynamics,2009, 47(5):627–640.
[12] 王福天.车辆系统动力学[M].北京：中国铁道出版社，1994：110.
{{custom_fnGroup.title_cn}}
脚注
{{custom_fn.content}}
PDF(1411 KB)
