基于超磁致伸缩驱动器的油膜轴承-转子系统的稳定性研究

吴超1,2,尹雪梅3,马明飞4,王文4,张直明4

振动与冲击 ›› 2020, Vol. 39 ›› Issue (1) : 57-61.

PDF(645 KB)
PDF(645 KB)
振动与冲击 ›› 2020, Vol. 39 ›› Issue (1) : 57-61.
论文

基于超磁致伸缩驱动器的油膜轴承-转子系统的稳定性研究

  • 吴超1,2,尹雪梅3,马明飞4,王文4,张直明4
作者信息 +

Stability of oil film bearing-rotor system based on GMA

  • WU Chao1,2,YIN Xuemei3, MA Mingfei4, WANG Wen4,ZHANG Zhiming4
Author information +
文章历史 +

摘要

以超磁致伸缩驱动器(GMA)油膜轴承-柔性转子系统为研究对象,计入轴承质量和转子刚度建立了包括GMA磁滞伸缩力模型在内的动力学方程,利用Routh-Hurwitz准则,推导了GMA油膜轴承所支承的单质量弹性对称转子系统的稳定性判据。考察了驱动GMA的反馈电流的相位角和电流大小、转子刚度、转子质量和轴承质量对系统失稳转速的影响。结果表明,反馈电流的相位角对系统失稳转速影响很大,存在一个最佳值,使系统的失稳转速最高,系统稳定性最佳,并随着反馈驱动电流和转子刚度的增大,失稳转速明显增大;随着转子质量的增加,系统的失稳转速也是增加的,而轴承的质量对系统的失稳转速影响不大。计算结果在GMA油膜轴承-转子系统整体建模方面有一定的意义。

Abstract

Taking an oil film bearing-rotor system based on GMA as the study object, considering bearing mass and rotor stiffness, its dynamic equation including a GMA magnetic hysteretic force model was established. Routh-Hurwitz criterion was used to derive the stability criterion for a single mass elastic symmetric rotor system supported by GMA oil-film bearings. Effects of rotor stiffness, rotor mass, bearing mass, phase angle and amplitude of feedback current to drive GMA on system unstable rotating speed were investigated. The results showed that phase angle of feedback current affects greatly system unstable rotating speed, and it has an optimal value to make system unstable rotating speed highest and system stability best; with increase in feedback driving current and rotor stiffness, unstable rotating speed increases obviously; with increase in rotor mass, system unstable rotating speed also increases, however, bearing mass has little influence on system unstable rotating speed; the calculated results provide a reference foroverall modeling of a GMA oil film bearing-rotor system.

关键词

超磁致伸缩驱动器 / 失稳转速 / 转子刚度 / 轴承质量

Key words

gaint magnetostrictive actuator (GMA) / unstable rotating speed / rotor stiffness / bearing mass

引用本文

导出引用
吴超1,2,尹雪梅3,马明飞4,王文4,张直明4. 基于超磁致伸缩驱动器的油膜轴承-转子系统的稳定性研究[J]. 振动与冲击, 2020, 39(1): 57-61
WU Chao1,2,YIN Xuemei3, MA Mingfei4, WANG Wen4,ZHANG Zhiming4. Stability of oil film bearing-rotor system based on GMA[J]. Journal of Vibration and Shock, 2020, 39(1): 57-61

参考文献

[1]  马柯达,吴超,付亚琴,等.应用于主动控制油膜轴承的超磁致伸缩驱动器的实验研究[J].润滑与密封,2009,34(1):36-39.
MA Keda,WU Chao,FU Yaqin,et al.Experiemtal investigation of gaint magnetostrictive actuators on actively controlled oil film bearing[J].Lubrication Engineering, 2009,34(1):36-39.
[2]  LAU H Y, LIU K P, WANG W, et al. Feasibility of using GMM based actuators in active control of journal bearing system[C].World Congress on Engineering 2009, London, U.K., 1-3 July, 2009:1493-1498
[3]  LAU H Y, LIU K P, WONG P L, et al. A new design of smart journal bearing based on GMM actuators[J]. Industrial Lubrication and Tribology, 2012,64(3):147-151.
[4]  FANG Z M, LI Z, WANG W. Smart journal bearing using gaint magnetostrictive actuators[C]. Proceedings of International Conference on Advances in Tribology and Engineering Systems 2013, Ahmedabad, India, October, 2013:381-390.
[5]  WANG W, CAI S Z, WU C, et al. Vibration Suppression Evaluation of Smart Journal Bearing Using Giant Magnetostrictive Actuators[J]. Key Engineering Materials, 2015, 642:323~327.
[6]  贾晨辉,庞焕杰,邱明.球面螺旋槽动静压气体轴承的动态特性分析及稳定性预测[J].航空动力学报,2017,32(6): 1400-1411.
    JIA Chenhui,PANG Huanjie, QIU Ming. Analysis of dynamic characteristics and stability prediction of spherical spiral groove hybrid gas bearings[J]. Journal of Aerospace Power, 2017, 32(6):1400-1411.
[7]  李梦暄,吴价,郑水英,等.不同轴瓦结构滑动轴承-转子系统的稳定性[J].浙江大学学报(工学版),2017,51(11):2239-2248.
LI Meng-xuan,WU Jia,ZHENU Shuryingz,et al. Stability of bearin-rotor system with different bearing structures[J]. Journal of Zhejiang University(Engineering Science),2017, 51(11): 2239-2248.
[8]  郭红,夏伯乾,孙一休.径向动静压浮环轴承-转子系统稳定性分析[J].振动与冲击,2017, 36(05):7-11+29.
GUO Hong,XIA Boqian,SUN Yixiu. Stability analysis of a journal floating ring hybrid bearing-rotor system[J]. Journal of Vibration and Shock,2017, 36(05):7-11+29.
[9]  郭增林,杨益华.滑动轴承转子系统多稳定区形态特性研究[J]. 机械强度,2001,23(2):138-140.
GUO Zenglin,YANG Yihua. Study on Pattern Characteristics of Multi Stable Regions of Hydrodynamic Bearing-Rotor System[J].Journal of Mechanical Strength,2001,23(2): 138-140.
[10] Wang W, Wu C, Wong P L. Experimental Investigation of Smart Journal Bearing with Giant Magnetostrictive Actuators[C]. 14th EDF/Pprime Workshop, Poitiers, Futuroscope, "Influence of design and materials on journal and thrust bearing performance”, October 8 & 9, 2015.
[11] 吴超,张永宇,纪莲清,等. GMA可控油膜轴承-转子系统不平衡响应的理论研究[J].润滑与密封,2009,34(9): 47-50.
WU Chao, ZHANG YongYu, JI Lianqing, et al. Theoretica1 investigation on unbalance response of controllable oi1 film bearing-rotor system with GMA[J].Lubrication Engineering, 2009,34(9):47-50.
[12] 熊万里,侯志泉,吕浪,等. 基于动网格模型的液体动静压轴承刚度阻尼计算方法[J].机械工程学报,2012,48(23): 118-126.
XIONG Wanli, HOU Zhiquan, LÜ Lang, et al. Method for calculating stiffness and damping coefficients of hybrid bearings based on dynamic mesh model[J]. Journal of Mechanical Engineering, 2012,48(23): 118-126.
[13] 尹雪梅,李蒙蒙,马明飞,等. 基于动网格方法的油膜轴承性能的研究[J].液压与气动,2018, (5): 54-57.
YIN Xuemei, LI Mengmeng, MA Mingfei, et al.Investigation based on dynamic mesh updating method for performance of oil film bearing[J].Chinese Hydraulics & Pneumatics,2018, (5): 54-57.
[14] 张直明.滑动轴承的流体动力润滑理论[M].北京:高等教育出版社,1986:211-222,276.
[15] 郭红,张直明,张绍林,等.径向动压浮环轴承-转子系统多稳定区域研究[J].振动与冲击,2016,35(02): 168-172.
GUO Hong, ZHANG Zhiming, ZHANG Shaolin, et al. Multi stable regions of hydrodynamic floating ring journal bearing-rotor system[J]. Journal of Vibration and Shock, 2016,35(02): 168-172.
[16] 吴超,尹雪梅,王文. GMA油膜轴承动态控制轴心轨迹的试验研究[J].中国机械工程,2016,27(1):41-45.
WU Chao, YIN Xuemei, WANG Wen. Testing research of rotor center trajectory of oil-film bearing with GMA under dynamic control[J].China Mechanical Engineering,2016,27 (1):41-45.

PDF(645 KB)

Accesses

Citation

Detail

段落导航
相关文章

/