湍流边界层激励下加筋平板振声响应特性研究

PDF(1847 KB)

振动与冲击 ›› 2020, Vol. 39 ›› Issue (14) : 156-163.

论文

徐嘉启，梅志远，李华东，周振龙

作者信息 +

Vbration & acoustic response characteristics of a stiffened plate stimulated by turbulent boundary layer wall pressure fluctuation

XU Jiaqi,MEI Zhiyuan,LI Huadong,ZHOU Zhenlong

Author information +

文章历史 +

摘要

船舶、汽车和飞机等高速运动时，其外壳受湍流边界层壁面脉动压力激励而产生的内场声辐射成为该类交通工具自噪声的重要成分。基于模态叠加法计算结构振动响应。采用湍流壁面脉动压力功率谱Corcos模型，计算了外侧气流或水流湍流边界层激励下简支平板振动及内场辐射声，计算值与解析解和试验值吻合良好，验证了算法的有效性。采用湍流壁面脉动压力功率谱改进型Corcos模型，研究了外侧水流湍流边界层激励下平板及板格的振声响应特性，结果表明：水流马赫数低，壁面脉动压力迁移波数大于平板结构弯曲波数，壁面脉动压力波数-频率谱的迁移脊对平板的激励作用可以忽略；横向或纵向加筋对板格振动速度自功率谱级基本无影响；减小板格宽度与长度之比，适当增大板格流向长度可使平板振动辐射声功率在2 000 Hz以上明显降低。

Abstract

While transportation vehicles such as ships，auto-mobiles and airplanes travel fast，the inward sound radiated by their outer surface vibration would become a vital part of the self-noise，this kind of vibration is induced by turbulent boundary layer wall pressure fluctuation．Structural vibration responses were calculated based on the modal summation．The Corcos model was used to estimate the power spectra of the turbulent boundary layer wall pressure fluctuation in the calculation of the vibration and inward sound radiation of a simply supported plate stimulated by outer air or water flow turbulent boundary layer.The calculation results fit well with analytical and experimental ones，which proves the validity of the method．Moreover, an improved Corcos model was used to estimate once more the power spectra，and the vibration and inward sound radiation characteristics of the simply supported plate stimulated by outer water flow turbulent boundary layer were investigated．The results indicate that, attributing to the low Mach number of the water flow，the convective wave number of wall fluctuating pressure is far greater than the plate structure flexural wave number，thus the stimulation caused by the convective ridge of the wave number-frequency spectra of wall fluctuating pressure could be neglected.Span-wise or stream-wise stiffeners do little effect on plate velocity auto-spectra.Decreasing the panel aspect ratio and properly increasing the panel stream-wise length would cause evident decrease on the plate radiated sound power above 2 000 Hz．

导出引用

徐嘉启，梅志远，李华东，周振龙. 湍流边界层激励下加筋平板振声响应特性研究[J]. 振动与冲击, 2020, 39(14): 156-163

XU Jiaqi,MEI Zhiyuan,LI Huadong,ZHOU Zhenlong. Vbration & acoustic response characteristics of a stiffened plate stimulated by turbulent boundary layer wall pressure fluctuation[J]. Journal of Vibration and Shock, 2020, 39(14): 156-163

参考文献

[1] CHEVALIER F，AUDOLY C．Turbulent Flow-Induced Self Noise and Radiated Noise in Naval Systems—An Industry Point of View[A]．Ciappi E，etal．Flinovia-Flow Induced Noise and Vibration Issues and Aspects[M]．Switzerland：Springer，2015：249-277．
[2] HWANG Y F，BONNESS W K，HABMRIC S A．On Modeling Structural Excitations by Low Speed Turbulent Boundary Layer Flows：Technical Report，03-008[R]．Ballston，VA，USA：Office of Naval Research，2003：30-34．
[3] STRAWDERMAN W A，CHRISTMAN R A．Turbulence-induced plate vibrations:some effects of fluid loading on finite and infinite plates[J]．The Journal of the Acoustical Society of America，1972，52（2）：1537-1552．
[4] MAZZONI D，KRISTIANSEN U．Flow，Turbulence and Combustion[M]．Netherlands：Kluwer Academic Publishers，1999：133-169．
[5] DAVIES H．Sound from turbulent-boundary-layer-excited panels[J]．The Journal of the Acoustical Society of America ，1969，49（3）：878-889．
[6] TOTARO N，GUYADER J L ．Model of Frequency Averaged Injected Power into a Plate Excited by a Turbulent Boundary Layer[J]．Acta Acustica United with Acustica，2003，89：647-657．
[7] GRAHAM W R．A comparision of models for the wavenumber-frequency spectrum of turbulent boundary layer pressures[J]．Journal of Sound and Vibration，1997，206：541-565．
[8] CIAPPI E，Magionesi F．Prediction of the noise level generated by the turbulent boundary layer on board a fast ship[C]．Honolulu，Hawaii：Inter-Noise 2006，2006．
[9] DE ROSA S，FRANCO F．Exact and numerical responses of a plate under a turbulentboundary layer excitation[J]．Journal of Fluids and Structures，2008，24：212-230．
[10] ROCHA J，SULEMAN A，LAU F．Prediction of flow-induced noise in transport vehicles:development and validation of a coupled structural-acoustic analytical framework[J]．Canadian Acoustics，2009，37（4）：13-29．
[11] VAN HERPE F，LOBEL G，LAFON P．Estimation of automotive wind noise by coupling direct noise computation to statistical energy analysis[C/OL]//Proceedings of 19th AIAA/CEAS Aeroacoustics Conference，Berlin，Germany：AIAA，2013．http://dx.doi.org/10.2514/6.2013-2227．
[12] CARO S，VINCENT C，SHERTER P，et al．Turbulent Surface Pressure Field in Low Speed Flow[M]．CIAPPIE，DE ROSA S，FRANCO F，et al．Flinovia-Flow Induced Noise and Vibration Issues and Aspects．Chambridge：Springer，2015：91-100．
[13] HWANG Y F．A discrete model of turbulence loading function for computation of flow-induced vibration and noise[C]//Proceedings of 1998 IMECE，Noise Control and Acoustics Division．Anaheim，USA：IMECE，1998：389-395．
[14] HAMBRIC S A，HWANG Y F，BONNESS W K．Vibrations of plates with clamped and free edges excited by low-speed turbulent boundary layer flow[J]．Journal of Fluids and Structures，2004，19： 93-110．
[15] BONNESS W K，FAHNLINE J B，LYSAK P D，et al．Modal forcing functions for structural vibration from turbulent boundary layer flow[J]．Journal of Sound and Vibration，2017，395：224-239．
[16] MAGIONESI F，DI MASCIO A. Investigation and modelling of the turbulent wall pressure fluctuations on the bulbous bow of a ship[J]. Journal of Fluids and Structures，2016，67：219-240．
[17] 陈美霞，魏建辉，乔志，等．湍流激励下结构振动特性的半解析半数值算法研究［J］．振动工程学报，2011，24：689-695．
CHEN Meixia，WEI Jianhui，QIAO Zhi，et al．Semi-analytical and semi-numerical method for calculating the vibration characteristics of structure excited by turbulent boundary layer[J]．Journal of Vibration Engineering，2011，24：689-695．
[18] CAO Xiongtao，HUA Hongxing．Acoustic responses of the composite sandwich plates with lattice truss core to the subsonic turbulent boundary layer[J]．Composite Structures，2016，153：176–192．
[19] 李东升，徐海宾，蔡卫丰等．声呐平台噪声控制机理分析[J]．船舶力学，2017，21（7）：907－913．
LI Dongsheng，XU Haibin，CAI Weifeng，et al．Mechanism analysis of noise control for Sonar Platform[J]．Journal of Ship Mechanics，2017，21（7）：907－913．
[20] HWANG Y F，BONNESS W K，HAMBRIC S A. Comparison of semi-empirical models for turbulent boundary layer wall pressure spectra[J]．Journal of Sound and Vibration，2009，319（1-2）：199-217．
[21] LI W L．An analytical solution for the self-and mutual radiation resistances of a rectangular plate[J]．Journal of Sound and Vibration，2001，245（1）：1-16．
[22] CIAPPI E，MAGIONESI F．Prediction of the noise level generated by the turbulent boundary layer on board a fast ship[C]//Proceedings of Inter-Noise and Noise-Con Congress and Conference．Honolulu，Hawaii，USA：Inter-Noise，2006：764-773．
[23] ROCHA J，SULEMAN A，LAU F．Turbulent boundary layer induced noise and vibration of a multi-panel walled acoustic enclosure[J]．Canadian Acoustics，2010，38（4）：9－22．
[24] LIU Bilong，ZHANG Hao，Qian Zhongchang，et al．Influence of stiffeners on plate vibration and radiated noise excited by turbulent boundary layers[J]．Applied Acoustics，2014，80：28-35．
[25] LIU Bilong．Noise radiation of aircraft panels subjected to boundary layer pressure fluctuations[J]．Journal of Sound and Vibration，2008，314：693－711．