加强筋流固耦合效应对板架结构爆炸毁伤特性影响分析

PDF(1796 KB)

振动与冲击 ›› 2020, Vol. 39 ›› Issue (22) : 207-213.

论文

刘聪1，张世联1，武少波1,2

作者信息 +

Analysis on the fluid-solid coupling effect of stiffeners on the explosion damage characteristics of grillage structures

LIU Cong1,ZHANG Shilian1,WU Shaobo1,2

Author information +

文章历史 +

摘要

为分析加强筋流固耦合效应对板架结构爆炸毁伤特性的影响，针对舰船某一典型局部板架结构建立计算模型，采用三种不同耦合加强筋腹板和面板的方法分别计算三种炸药量下其爆炸载荷分布、响应以及毁伤后剩余极限强度，并对计算结果进行对比分析。结果表明：考虑加强筋流固耦合效应后爆炸载荷将产生局部增强，对板架结构的载荷分布和毁伤效果影响极大；对迎爆加筋板进行仿真计算时，必须对加强筋腹板进行耦合处理；加强筋面板流固耦合效应对计算结果影响远低于加强筋腹板，分析结构剩余极限强度时，可忽略加强筋面板耦合。

Abstract

In order to study the fluid-solid coupling effect of stiffeners on the explosion damage characteristics, a typical ship partial grillage structure was modeled.Three spherical masses of explosive were detonated at a constant distance apart from the target structure on three different coupling degrees, and the load distribution, structural response and residual ultimate strength were calculated and analyzed.The results show that the explosion load will be increased locally when the stiffener coupling effect is considered, which has a great influence on the load distribution and damage results.The web effect must be considered in stiffener coupling simulations, while the wing has less effect on the coupling calculation accuracy than the web, and can be neglected when the residual ultimate strength of structure is only concerned.

导出引用

刘聪1，张世联1，武少波1,2. 加强筋流固耦合效应对板架结构爆炸毁伤特性影响分析[J]. 振动与冲击, 2020, 39(22): 207-213

LIU Cong1,ZHANG Shilian1,WU Shaobo1,2. Analysis on the fluid-solid coupling effect of stiffeners on the explosion damage characteristics of grillage structures[J]. Journal of Vibration and Shock, 2020, 39(22): 207-213

参考文献

[1] Houlston R , Desrochers C G . Nonlinear structural response of ship panels subjected to air blast loading[J]. Computers & Structures, 1987, 26(1):1-15.
[2] Houlston R , Slater J E . Damage analysis with ADINA of naval panels subjected to a confined air-blast wave[J]. Computers & Structures, 1993, 47(4-5):629-639.
[3] 刘土光, 胡要武, 郑际嘉. 固支加筋方板在爆炸载荷作用下的刚塑性动力响应分析[J]. 爆炸与冲击, 1994, 14(1):55- 65.
    LIU Tuguang , HU Yaowu , ZHENG Jijia. Dynamic response analysis of rigid perfectly plastic clamped square plates with stiffener subjected to blast loading[J]. Explosion and Shock Waves, 1994, 14(1):55-65.
[4] 吴有生,彭兴宁,赵本立.爆炸载荷作用下舰船板架的变形与破损[J]. 中国造船, 1995,36(04):55-61.
    WU Yousheng, PENG Xingning, ZHAO Benli. Plastic deformation and damage of naval panels subjected to explosion loading[J]. Shipbuilding of China, 1995, 36(04):55- 61.
[5] 唐文勇, 陈铁云. 加筋板结构的塑性动力响应分析[J]. 上海交通大学学报, 1996, 30(8):73-80.
    TANG Wenyong, CHEN Tieyun. An analysis of dynamic plastic response of stiffened plates[J]. Journal of Shanghai Jiaotong University, 1996, 30(8):73-80.
[6] Yuen S C K , Nurick G N . Experimental and numerical studies on the response of quadrangular stiffened plates. Part I: Subjected to uniform blast load[J]. International Journal of Impact Engineering, 2005, 31(1):55-83.
[7] Langdon G S , Yuen S C K , Nurick G N . Experimental and numerical studies on the response of quadrangular stiffened plates. Part II: localised blast loading[J]. International Journal of Impact Engineering, 2005, 31(1):85-111.
[8] Curry R J , Langdon G S . Transient response of steel plates subjected to close proximity explosive detonations in air[J]. International Journal of Impact Engineering, 2017, 102:102- 116.
[9] 吴林杰, 朱锡, 侯海量, 等. 空中近距爆炸下加筋板架的毁伤模式仿真研究[J]. 振动与冲击，2013, 32(14): 77-81.
WU Linjie, ZHU Xi, HOU Hai-liang, et al. Numerical study on the damage mode of stiffened plates subjected to close-range air-blast loading[J]. Journal of Vibration and Shock, 2013, 32(14): 77-81.
[10] 王世来. 大型水面舰船防护水舱内爆炸的数值模拟[J]. 浙江工业大学学报, 2007, 35(3):262-266.
    WANG Shilai. The explosion numerical simulation in the protective water cabin of large surface warship[J]. Journal of Zhejiang University of Technology, 2007, 35(3):262-266.
[11] 孔祥韶, 吴卫国, 李晓彬, 等. 舰船舱室内部爆炸的数值模拟研究[J]. 中国舰船研究, 2009, 4(4):7-11.
    KONG Xiangshiao, WU Weiguo, LI Xiaobin, et al. Numrical simulation of cabin structure under inner explosion[J]. Chinese Journal of Ship Research, 2009, 4(4):7-11.
[12] Zheng C , Kong X S , Wu W G , et al. The elastic-plastic dynamic response of stiffened plates under confined blast load[J]. International Journal of Impact Engineering, 2016, 95:141-153.
[13] Chen P W , Liu H , Ding Y S , et al. Dynamic Deformation of Clamped Circular Plates Subjected to Confined Blast Loading[J]. Strain, 2016, 52(6):478-491.
[14] Pickerd V, Bornstein H, McCarthy P, et al. Analysis of the structural response and failure of containers subjected to internal blast loading[J]. International Journal of Impact Engineering, 2016, 95:40-53.
[15] Zheng C , Kong X S , Wu W G , et al. Experimental and numerical studies on the dynamic response of steel plates subjected to confined blast loading[J]. International Journal of Impact Engineering, 2018, 113:144-160.
[16] 孔祥韶, 徐维铮, 郑成, 等. 多层防护结构舱内爆炸试验[J]. 船舶力学, 2017, 21(1):76-89.
    KONG Xiangshao, XU Weizheng, ZHENG Cheng, et al. Experiment of a multi-layer protective structure under an inner explosion[J]. Journal of Ship Mechanics, 2017, 21(1):76-89.
[17] 郑成,孔祥韶,徐维铮,等.舱内爆炸载荷作用下加筋板动态响应试验研究[J].中国造船,2018,59(02):129-139.
    ZHENG Cheng, KONG Xiangshao, XU Weizheng, et al. Experimental Study on Dynamic Response of Stiffened Plates Subjected to Internal Blast Loads[J]. Shipbuilding of China, 2018,59(02):129-139.
[18] 李聪. 箱型梁舱段舱内爆炸及剩余极限强度研究[D]. 上海交通大学, 2013.
    LI Cong. Study on inner explosion and residual ultimate strength of hold with longitudinal box girder[D]. Shanghai Jiao Tong University, 2013.
[19] 侯海量, 朱锡, 李伟, 等. 舱内爆炸冲击载荷特性实验研究[J]. 船舶力学, 2010, 14(8):901-907.
    HOU Hailiang, ZHU Xi, LI Wei, et al. Experimental studies on characteristics of blast loading when exploded inside ship cabin[J]. Journal of Ship Mechanics, 2010, 14(8):901-907.
[20] 樊壮卿, 王伟力, 黄雪峰, 等. 典型舱室内爆炸仿真分析[J]. 工程爆破, 2015, 21(3):13-17.
    FAN Zhuangqing, WANG Weili, HUANG Xuefeng, et al. Simulation analysis on typical cabin internal explosion[J]. Engineering Blasting, 2015, 21(3):13-17.
[21] 侯海量, 朱锡, 梅志远. 舱内爆炸载荷及舱室板架结构的失效模式分析[J]. 爆炸与冲击, 2007, 27(2):151-158.
    HOU Hailiang, ZHU Xi, MEI Zhiyuan. Study on the blast load and failure mode of ship structure subject to internal explosion[J]. Explosion and Shock Waves, 2007, 27(2):151- 158.
[22] 梅志远, 朱锡, 刘润泉. 船用加筋板架爆炸载荷下动态响应数值分析[J]. 爆炸与冲击, 2004, 24(1):80-84.
    MEI Zhiyuan, ZHU Xi, LIU Runquan. Dynamic response researches of ship’s stiffened plate structure under explosive load[J]. Explosion and Shock Waves, 2004, 24(1):80-84.