侵彻条件下岩石类材料RHT模型参数敏感性分析

PDF(2188 KB)

振动与冲击 ›› 2021, Vol. 40 ›› Issue (14) : 108-116.

论文

聂铮玥，彭永，陈荣，蔡镇清，李付刚

作者信息 +

Sensitivity analysis of RHT model parameters for rock materials under penetrating condition

Zhengyue，PENG Yong，CHEN Rong，CAI Zhenqing，LI Fugang

Author information +

文章历史 +

摘要

材料模型的参数敏感性分析对于简化材料参数确定及精确仿真计算结果具有重要意义。针对弹体侵彻半无限厚岩石靶体问题，考虑多种类型岩石的材料参数变化范围及参数间的非独立性，利用优化拉丁超立方设计(Opt LHD)算法设计了RHT模型参数计算矩阵并开展了参数敏感性分析，克服了以往研究中常采用单因素变量法进行分析的不足。分别以侵彻深度、弹体质量损失率及靶体损伤度为评价指标，结合355个有效数值仿真结果，分析了参数间的交互效应。结果表明，参数间存在交互效应，但总体参数组合对三类评价指标的交互效应均不显著，因此，进一步对参数进行了主效应分析。为了定量评价参数敏感性差异，通过建立参数与评价指标间的响应面模型，基于多元二次回归模型计算了参数贡献率，进一步得到了对于不同评价指标的材料参数敏感性排序结果。

Abstract

The sensitivity analysis of material model parameters is very important for simplifying the determination of material parameters and acquisition of accurate simulation results.For the problem of projectile penetrating into semi-infinite rock target, considering the variation range and the non-independence of rock material parameters, the optimal Latin hypercube design (Opt LHD) algorithm was used to design the parameter calculation matrix, which overcomes the shortcomings of monofactor analysis method.Taking penetration depth, projectile mass loss rate and target damage degree as evaluation indexes, the interaction effects between parameters were analyzed based on 355 effective numerical simulation results.The results show that there are interaction effects among the parameters, but the interaction effects of the overall parameter combination on the three types of evaluation indicators are not significant, therefore, the main effects of parameters were further analyzed.In order to quantitatively evaluate the sensitivity difference between parameters, the parameters contribution rate were calculated by establishing response surface models between the parameters and the evaluation indexes, and the material parameter sensitivity ranking results for different evaluation indexes were further obtained.

导出引用

聂铮玥，彭永，陈荣，蔡镇清，李付刚. 侵彻条件下岩石类材料RHT模型参数敏感性分析[J]. 振动与冲击, 2021, 40(14): 108-116

NIE Zhengyue，PENG Yong，CHEN Rong，CAI Zhenqing，LI Fugang. Sensitivity analysis of RHT model parameters for rock materials under penetrating condition[J]. Journal of Vibration and Shock, 2021, 40(14): 108-116

参考文献

［1］李忠献，刘泽锋.混凝土动态本构模型综述［J］.天津大学学报(自然科学与工程技术版)，2015, 48(10): 854-863.
LI Zhongxian, LIU Zefeng.Review of concrete dynamic constitutive model［J］.Journal of Tianjin University (Science and Technology), 2015,48(10): 854-863.

［2］LEPPNEN J.Concrete subjected to projectile and fragment impacts: modelling of crack softening and strain rate dependency in tension［J］.International Journal of Impact Engineering, 2006,32(11): 1828-1841.

［3］金乾坤.混凝土动态损伤与失效模型［J］.兵工学报，2006,27(1): 10-14.
JIN Qiankun.Dynamic damage and failure model for concrete materials［J］.Acta Armamentarii, 2006,27(1): 10-14.

［4］GRUNWALD C, SCHAUFELBERGER B, STOLZ1 A, et al.A general concrete model in hydrocodes: verification and validation of the Riedel-Hiermaier-Thoma model in LS-DYNA［J］.International Journal of Protective Structures, 2017,8(1): 58-85.

［5］施德胜，施冠银，陈江瑛.RHT模型的改进与数值拟合［J］.宁波大学学报(理工版), 2014,27(3): 94-96.
SHI Desheng, SHI Guanyin, CHEN Jiangying.Improvement and numerical fitting of RHT model［J］.Journal of Ningbo University (NSEE), 2014,27(3): 94-96.

［6］张若棋，丁育青，汤文辉，等.混凝土HJC、RHT本构模型的失效强度参数［J］.高压物理学报, 2011,25(1): 16-21.
ZHANG Ruoqi, DING Yuqing, TANG Wenhui, et al.The failure strength parameters of HJC and RHT concrete constitutive model［J］.Chinese Journal of High Pressure Physics, 2011,25(1): 16-21.

［7］PAVLOVIC A, FRAGASSA C, DISIC A.Comparative numerical and experimental study of projectile impact on reinforced concrete［J］.Composites Part B, 2007,108: 122-130.

［8］ABDEL-KADER M.Modified settings of concrete parameters in RHT model for predicting the response of concrete panels to impact［J］.International Journal of Impact Engineering, 2019,132: 103312.

［9］李洪超.岩石RHT模型理论及主要参数确定方法研究［D］. 北京：中国矿业大学, 2016.

［10］李洪超，刘殿书，赵磊，等.大理岩RHT模型参数确定研究［J］.北京理工大学学报，2017,37(8): 802-806.
LI Hongchao, LIU Dianshu, ZHAO Lei, et al.Study on parameters determination of marble RHT model［J］.Transactions of Beijing Institute of Technology, 2017,37(8): 802-806.

［11］李洪超，陈勇，刘殿书，等.岩石RHT模型主要参数敏感性及确定方法研究［J］.北京理工大学学报, 2018,38(8): 780-785.
LI Hongchao, CHEN Yong, LIU Dianshu, et al.Sensitivity analysis determination and optimization of rock RHT parameters［J］.Transactions of Beijing Institute of Technology, 2018,38(8): 780-785.

［12］刘殿柱，刘娜，高天赐，等.应用正交试验法的RHT模型参数敏感性研究［J］.北京理工大学学报，2019,39(6): 559-564.
LIU Dianzhu, LIU Na, GAO Tianci, et al.Study on the parameter sensitivity of RHT concrete model by orthogonal test technique［J］.Transactions of Beijing Institute of Technology, 2019,39(6): 559-564.

［13］辛健.爆炸作用下RHT模型参数敏感性分析［J］.舰船电子工程, 2019,39(4): 112-113.
XIN Jian.Sensitivity analysis of RHT model parameters under explosive attack［J］.Ship Electronic Engineering, 2019,39(4): 112-113.

［14］RIEDEL W, THOMA K, HIERMAIER S, et al.Penetration of reinforced concrete by BETA-B-500 numerical analysis using a new macroscopic concrete model for hydrocodes［C］//9th International Symposium on the Interaction of the Effects of Munitions with Structures.Berlin: ISIEMS, 1999.

［15］HERRMANN W.Constitutive equation for the dynamic compaction of ductile porous materials［J］.Journal of Applied Physics, 1969,40(6): 2491-2499.

［16］张雄，廉艳平，刘岩．物质点法［M］.北京：清华大学出版社，2013.

［17］HOLMQUIST T J, JOHNSON G R, COOK W H.A computational constitutive model for concrete subjected to large strains, high strain rates and high pressures［C］// Proceedings of 14th International Symposium on Ballistics.Quebec: ISB, 1993.

［18］BORRVALL T, RIEDEL W.The RHT concrete model in LS-DYNA［C］//Proceeding of the 8th European LS-DYNA Users Conference.Strasbourg: ［s.n.］, 2011.

［19］刘佑荣，唐辉明.岩体力学［M］.北京：化学工业出版社, 2008.

［20］赵坚，赵宇辉，尚嘉兰，等.Bukit Timah花岗闪长岩的Hugoniot状态方程［J］.岩土工程学报， 1999,21(3): 315-318.
ZHAO Jian, ZHAO Yuhui, SHANG Jialan, et al.The Hugoniot equation of state for Bukit Timah granite［J］.Chinese Journal of Geotechnical Engineering, 1999,21(3): 315-318.

［21］ZHANG Q B, BRAITHWAITE C H, ZHAO J.Hugoniot equation of state of rock materials under shock compression［J］. Philosophical Transactions of the Royal Society A Mathematical Physical & Engineering Sciences, 2017,375(2085): 20160169.

［22］王占江，张德志，张向荣，等.蓝田花岗岩冲击压缩特性的实验研究［J］.岩石力学与工程学报, 2003,22(5): 797-802.
WANG Zhanjiang, ZHANG Dezhi, ZHANG Xiangrong, et al.Testing study on shock compression for Lantian granite［J］.Chinese Journal of Rock Mechanics and Engineering, 2003,22(5): 797-802.

［23］信礼田，颜潮兴.砂岩冲击压缩和卸载特性［J］.岩土工程学报, 1987,9(5): 58-66.
XIN Litian, YAN Chaoxing.Impact compression and unloading characteristics of sandstone［J］.Chinese Journal of Geotechnical Engineering, 1987,9(5): 58-66.

［24］赖宇阳, 姜欣, 方立桥，等.Isight参数优化理论与实例详解［M］.北京：北京航空航天大学出版社，2012.

［25］李磊，张先锋，吴雪，等.不同硬度30CrMnSiNi2A钢的动态本构与损伤参数［J］.高压物理学报, 2017,31(3): 240-248.
LI Lei, ZHANG Xianfeng, WU Xue, et al.Dynamic constitutive and damage parameters of 30CrMnSiNi2A steel with different hardnesses［J］.Chinese Journal of High Pressure Physics, 2017,31(3): 240-248.