非线性汽流激振力对超超临界汽轮机转子运动特性的影响

PDF(1961 KB)

振动与冲击 ›› 2021, Vol. 40 ›› Issue (17) : 25-31.

论文

曹丽华，颜洪，司和勇

作者信息 +

Effects of nonlinear steam flow exciting force on motion characteristics of ultra-supercritical steam turbine rotor

CAO Lihua, YAN Hong, SI Heyong

Author information +

文章历史 +

摘要

汽流激振力严重影响超超临界汽轮机的安全稳定运行，为此建立某1 000 MW汽轮机高压缸1.5级的三维全周模型，通过数值模拟得到不同负荷下的非线性汽流激振力，将汽流激振力耦合到转子-轴承-密封系统中，利用Runge-Kutta法求解微分方程组，对转子非线性运动特性进行分析。结果表明：随着转速升高，转子运动幅度变小，额定转速下转子处于一周期运动。随着负荷增加，系统由带混沌倾向的周期性运动向周期性的混沌运动过渡，此后进入复杂紊乱的混沌运动。非线性汽流激振力以分频的形式影响转子运动。低负荷时，振动频率以1/2工频为主，随着负荷升高，振动以工频为主，期间还出现1/3、2/3工频振动。受非线性汽流激振力的影响，转子系统处于混沌运动，最大Lyapunov指数大于零，系统可能失稳。

Abstract

Steam flow exciting force seriously affects safe and stable operation of an ultra-supercritical steam turbine.Here, a 3-D full cycle model for 1.5 stage high pressure cylinder of a 1 000 MW steam turbine was established.Nonlinear steam flow exciting forces under different loads were obtained using numerical simulation.The steam flow exciting force was coupled into a rotor-bearing-seal system to establish the system’s dynamic model, Runge-Kutta method was used to solve dynamic differential equations, and nonlinear motion characteristics of the rotor system were analyzed.The results showed that with increase in rotor rotating speed, the rotor vibration amplitude becomes smaller, and it is in a periodic motion under the rated rotating speed; with increase in load, the rotor system transits from periodic motion with chaotic tendency to periodic chaotic motion, and then enters complex chaotic motion; nonlinear steam flow exciting force affects the rotor motion in the form of frequency division; when load is low, the system vibration frequency is mainly 1/2 power frequency; with increase in load, the system vibration frequency is mainly power frequency, during this period, there are vibrations with 1/3 and 2/3 power frequencies too; due to effects of nonlinear steam flow exciting force, the rotor system is in chaotic motion, if the maximum Lyapunov exponent is larger than zero, the system may lose stability.

导出引用

曹丽华，颜洪，司和勇. 非线性汽流激振力对超超临界汽轮机转子运动特性的影响[J]. 振动与冲击, 2021, 40(17): 25-31

CAO Lihua, YAN Hong, SI Heyong. Effects of nonlinear steam flow exciting force on motion characteristics of ultra-supercritical steam turbine rotor[J]. Journal of Vibration and Shock, 2021, 40(17): 25-31

参考文献

［1］LFORD J S.Protecting turbomachinery from self-excited rotor whirl［J］.Journal of Engineering for Power, 1965,87(4):333-344.
［2］CHEN L, HU N S.Fault diagnosis for steam-flow exciting vibration of ultra supercritical 1 000 MW steam turbine［J］.Open Mechanical Engineering Journal, 2015,9(1):1067-1075.
［3］CAO L H, WANG J X, LI P, et al.Numerical analysis on steam exciting force caused by rotor eccentricity［J］.Shock and Vibration, 2017,2017:1-9.
［4］LI J L, GUO X H, YU C, et al.Catastrophe model of steam flow excitation vibration in steam turbine governing stage［J］.Proceedings of the CSEE, 2013,33(11):39-46.
［5］李彬, 宋立明, 李军.长叶片透平级非定常汽流激振数值研究［J］.工程热物理学报, 2016,37(1):56-61.
LI Bin, SONG Liming, LI Jun.Numerical study on unsteady steam induced vibration of long blade turbine stage ［J］.Journal of Engineering Thermophysics, 2016,37(1): 56-61.
［6］屈焕成, 张荻, 谢永慧, 等.汽轮机调节级非定常流动的数值模拟及汽流激振力研究［J］.西安交通大学学报, 2011,45(11):39-44.
QU Huancheng, ZHANG Di, XIE Yonghui, et al.Numerical simulation of unsteady flow in the governing stage of steam turbine and research on the excitation force of steam flow ［J］.Journal of Xi’an Jiaotong University, 2011,45(11): 39-44.
［7］LI Z G, CHEN Y S.Research on 1∶2 subharmonic resonance and bifurcation of nonlinear rotor-seal system［J］.Applied Mathematics and Mechanics-English Edition, 2012,33(4):499-510.
［8］HUANG D.Models of steam force and torque of a rotor subjected to the leakage of tip clearance［J］.Proceedings of the Institution of Mechanical Engineers, Part A: Journal of Power and Energy, 2002,216(5):355-361.
［9］谌莉.1 000 MW超超临界汽轮机汽流激振特性研究与应用［D］.武汉: 武汉大学, 2017.
［10］KIM H S, CHAO M, SONG S J.Stability analysis of a turbine rotor system with Alford forces［J］.Journal of Sound and Vibration, 2002,258(4):777-790.
［11］瓮雷, 杨自春, 曹跃云.汽轮机非线性间隙气流激振力作用下含裂纹转子的振动特性研究［J］.振动与冲击, 2016,35(5):89-95.
WENG Lei, YANG Zichun, CAO Yueyun.Study on the vibration characteristics of cracked rotor under the action of nonlinear gap air flow excitation force of steam turbine ［J］.Journal of Vibration and Shock, 2016,35(5): 89-95.
［12］刘思涌, 薛自华, 陆圯, 等.迷宫密封-转子系统非线性动力学模型及求解［J］.振动与冲击, 2012,31(13):41-45.
LIU Siyong, XUE Zihua, LU Yi, et al.Nonlinear dynamic model and solution of labyrinth seal-rotor system ［J］.Journal of Vibration and Shock, 2012,31(13): 41-45.
［13］张恩杰, 焦映厚, 陈照波, 等.迷宫密封激振力作用下转子系统非线性动力学分析［J］.振动与冲击, 2016,35(9):159-163.
ZHANG Enjie, JIAO Yinghou, CHEN Zhaobo, et al.Nonlinear dynamic analysis of rotor system under the excitation force of labyrinth seal ［J］.Journal of Vibration and Shock, 2016,35(9): 159-163.
［14］杨懿, 李蔚, 陈坚红, 等.受汽封力作用的连续转子模型研究［J］.核动力工程, 2010,31(6):20-23.
YANG Yi, LI Wei, CHEN Jianhong, et al.Study on the continuous rotor model under the action of steam seal force ［J］.Nuclear Power Engineering, 2010,31(6): 20-23.
［15］ZHANG E J, JIAO Y H, CHEN Z B, et al.Parametric influences on the nonlinear dynamic responses of a rotor-bearing-foundation-labyrinth seal system ［C］// Proceedings of the ASME International Mechanical Engineering Congress and Exposition.New York,2017.
［16］LI J L, GUO X H, YU C, et al.Catastrophe performance analysis of steam-flow-excited vibration in the governing stage of large steam turbines with partial admission［J］.Journal of Energy Resources Technology—Transactions of the ASME, 2013,135(4):1-8.
［17］谷伟伟, 徐自力.干摩擦阻尼叶片的界面约束力描述及振动响应求解［J］.振动工程学报, 2012,25(1):64-67.
GU Weiwei, XU Zili.Interface binding force description and vibration response solution of dry friction damper blade ［J］.Journal of Vibration Engineering, 2012,25(1): 64-67.
［18］曹丽华, 司和勇, 李盼, 等.基于动网格技术的转子动力特性研究［J］.工程热物理学报, 2019,40(8):1784-1792.
CAO Lihua, SI Heyong, LI Pan, et al.Research on dynamic characteristics of rotor based on dynamic grid technology ［J］.Journal of Engineering Thermophysics, 2019,40(8): 1784-1792.
［19］李志刚.袋型阻尼密封泄漏特性和转子动力特性的研究［D］.西安:西安交通大学, 2017.
［20］曹丽华, 司和勇, 李盼, 等.汽轮机转子动力特性的多因素分析及稳定性预测［J］.中国电机工程学报, 2018,38(3):823-831.
CAO Lihua, SI Heyong, LI Pan, et al.Multi factor analysis and stability prediction of steam turbine rotor dynamic characteristics ［J］.Chinese Journal of Electrical Engineering, 2018,38(3): 823-831.
［21］司和勇, 曹丽华, 李盼.耦合热、动载荷的超超临界汽轮机迷宫密封动力特性［J］.航空动力学报, 2019,34(9):1905-1913.
SI Hehong, CAO Lihua, LI Pan.Dynamic characteristics of labyrinth seals of ultra supercritical steam turbines under coupled thermal and dynamic loads ［J］.Journal of Aeronautical Power, 2019,34(9): 1905-1913.
［22］曹丽华, 王熙, 司和勇, 等.汽轮机动叶栅内泄漏流动特性及损失分布［J］.中国电机工程学报, 2019,39(21):6328-6336.
CAO Lihua, WANG Xi, SI Heyong, et al.Leakage flow characteristics and loss distribution in turbine cascades ［J］.Chinese Journal of Electrical Engineering, 2019,39(21): 6328-6336.
［23］ADILETTA G, GUIDO A R, ROSSI C.Chaotic motions of a rigid rotor in short journal bearings［J］.Nonlinear Dynamics, 1996,10(3):251-269.
［24］吕金虎.混沌时间序列分析及其应用［M］.武汉: 武汉大学出版社, 2002.