基于动载试验荷载效率的简支梁桥冲击系数研究

PDF(3690 KB)

振动与冲击 ›› 2021, Vol. 40 ›› Issue (20) : 207-216.

论文

周勇军1,2，赵洋1，赵煜1,2，曹群3，李珍1

作者信息 +

A study on dynamic load allowance of a simply supported girder bridge based on load efficiency of a dynamic load test

ZHOU Yongjun1,2,ZHAO Yang1,ZHAO Yu1,2,CAO Qun3,LI Zhen1

Author information +

文章历史 +

摘要

为对中小跨径简支梁桥冲击系数进行评价，建立轻荷载作用与等效设计荷载作用下冲击系数的关系。采用五自由度三轴平面车辆模型，以标准跨径的简支小箱梁桥为研究对象，建立车桥耦合振动方程，采用ANSYS软件二次开发语言APDL进行仿真求解。通过荷载等效原理，将设计荷载的车道荷载还原为等效的多辆重车荷载，进行准设计状态分析；基于动载试验荷载效率研究单辆车作用下各片主梁冲击系数的变化规律，对比分析不同因素对冲击系数的影响规律；最后提出基于动载试验荷载效率的轻荷载冲击系数修正方法。结果表明：现行规范取值的冲击系数偏不安全，但在桥面状况良好和低速行驶时安全性较高；冲击系数随动载试验荷载效率增大而减小，通过轻荷载所得的冲击系数直接与规范值对比没有实际意义；轻荷载的冲击系数经过修正后可还原为准设计状态下冲击系数。研究结论可为中小跨径桥梁设计提供参考，同时为桥梁动载试验的评价方法提供依据。

Abstract

In order to evaluate the impact coefficient of small and medium span simply supported beam bridges, the relationship between the impact coefficient under light load and the impact coefficient under equivalent design load was established.The vehicle-bridge coupling vibration equation was established by using the five-degree-of-freedom three-axis plane model and the standard span simply supported small box girder bridge as the research object, and the simulation solution was carried out by using the secondary development language APDL of ANSYS software.Firstly, through the load equivalent principle, the lane load of the design load was reduced to the equivalent heavy vehicle load, and the quasi-design state analysis was carried out; secondly, based on the dynamic load test load efficiency, the change law of the impact coefficient of each main beam under the action of a single vehicle was studied, and the influence of different factors on the impact coefficient was compared and analyzed.Finally, a light load impact coefficient correction method based on the dynamic load test was proposed.The results show that the impact coefficient of the current code is unsafe, but it is higher when the bridge deck is in good condition and at low speed, and the impact coefficient decreases with the increase of dynamic load test load efficiency.There is no practical significance to compare the impact coefficient obtained by light load directly with the code value, and the impact coefficient of light load can be reduced to the impact coefficient of quasi-design state after correction.The research conclusions can provide reference for the design of small and medium-span bridges and provide a basis for the evaluation method of bridge dynamic load test.

导出引用

周勇军，赵洋，赵煜，曹群，李珍. 基于动载试验荷载效率的简支梁桥冲击系数研究[J]. 振动与冲击, 2021, 40(20): 207-216

ZHOU Yongjun,ZHAO Yang,ZHAO Yu,CAO Qun,LI Zhen. A study on dynamic load allowance of a simply supported girder bridge based on load efficiency of a dynamic load test[J]. Journal of Vibration and Shock, 2021, 40(20): 207-216

参考文献

［1］施尚伟, 杜松, 李莹雪.桥梁冲击系数随机性分析［J］.重庆交通大学学报（自然科学版）, 2012,31(3): 377-379.
SHI Shangwei,DU Song,LI Yingxue.Randoms analysis of bridge impact coefficient［J］.Journal of Chongqing Jiaotong University(Natural Science), 2012,31(3): 377-379.

［2］朱劲松, 香超, 祁海东.大跨度悬索桥冲击系数影响因素研究［J］.天津大学学报(自然科学与工程技术版), 2019, 52(4): 413-422.
ZHU Jinsong,XIANG Chao,QI Haidong.Study of influencing factors of impact coefficient of long-Span suspension bridge［J］.Journal of Tianjin University(Science and Technology), 2019, 52(4): 413-422.

［3］徐文涛, 廖敬波, 张泽通, 等.基于参数识别的桥梁冲击系数随机响应优化方法［J］.机械工程学报, 2018, 54(12): 64-70.
XU Wentao,LIAO Jingbo,ZHANG Zetong, et al.Numerical method study of key factor identification and parameter optimization for dynamic impact on bridge based on the pseudo-excitation method［J］.Journal of Mechanical Engineering, 2018, 54(12): 64-70.

［4］邓露, 陈雅仙, 韩万水, 等.中小跨径公路混凝土简支梁桥冲击系数研究及建议取值［J］.中国公路学报, 2020,33(1): 69-78.
DENG Lu,CHEN Yaxian,HAN Wanshui, et al.Studying impact factors for short and medium span Simply Supported concrete highway bridges and its suggested values［J］.China Joural of Highway and Transport, 2020,33(1): 69-78.

［5］刘晨光, 王宗林, 高庆飞.考虑桥面不平整度退化的简支梁桥冲击系数检测方法研究［J］.振动与冲击, 2019,38(1): 206-214.
LIU Chenguang,WANG Zonglin,GAO Qingfei.Impact coefficient detecting method for a simply supported girder bridge considering degradation of deck unevenness［J］.Journal of Vibration and Shock, 2019,38(1): 206-214.

［6］WANG T L, HUANG D.Cable-stayed bridge vibration due to road surface roughness［J］.Journal of Structural Engineering, 1992,118(5): 1354-1374.

［7］OBRIEN E J, CANTERO D, ENRIGHT B, et al.Characteristic Dynamic Increment for extreme traffic loading events on short and medium span highway bridges［J］.Engineering Structures, 2010,32(12): 3827-3835.

［8］蒋培文. 公路大跨径连续体系桥梁车桥耦合振动研究［D］.西安: 长安大学, 2012.

［9］邓露, 何维, 俞扬, 等.公路车-桥耦合振动的理论和应用研究进展［J］.中国公路学报, 2018,31(7): 38-54.
DENG Lu,HE Wei,YU Yang, et al.Research progress in theory and applications of highway vehicle-bridge coupling vibration［J］.China Joural of Highway and Transport, 2018,31(7): 38-54.

［10］吴铭汉, 桂水荣, 陈水生.4种车辆模型作用下T形刚构桥冲击系数对比研究［J］.中外公路, 2008,28(6): 130-133.
WU Minghan,GUI Shuirong,CHEN Shuisheng.Comparative study on impact coefficient of T-shaped rigid frame bridge under the action of four vehicle models［J］.Journal of China & Foreign Highway, 2008,28(6): 130-133.

［11］HUANG D, WANG T L, SHAHAWY M.Impact studies of multigirder concrete bridges［J］.Journal of Structural Engineering, 1993,119(8): 2387-2402.

［12］KWASNIEWSKI L, WEKEZER J, ROUFA G, et al.Experimental evaluation of dynamic effects for a selected highway bridge［J］.Journal of Performance of Constructed Facilities, 2006,20(3): 253-260.

［13］MOGHIMI H, RONAGH H R.Development of a numerical model for bridge-vehicle interaction and human response to traffic-induced vibration［J］.Engineering Structures, 2008,30(12): 3808-3819.

［14］WANG T L, HUANG D, SHANAWY M.Dynamic response of multigirder bridges［J］.Journal of Structural Engineering, 1992,118(8): 2222-2238.

［15］陈水生, 李孟廷, 桂水荣, 等.多车激励公路简支梁车桥耦合振动响应分析［J］.武汉理工大学学报, 2014,36(3): 101-106.
CHEN Shuisheng,LI Mengting,GUI Shuirong, et al.Analysis on the vehicle-bridge coupling vibration for highway simple bridges due to moving multi-vehicles loading［J］.Journal of Wuhan University of Technology, 2014,36(3): 101-106.

［16］BROQUET C, BAILEY S F, FAFARD M, et al.Dynamic behavior of deck slabs of concrete road bridges［J］.Journal of Bridge Engineering, 2004,9(2): 137-146.

［17］HUANG D. Vehicle-Induced vibration of steel deck arch bridges and analytical methodology［J］.Journal of Bridge Engineering, 2012,17(2): 241-248.

［18］韩万水, 闫君媛, 武隽, 等.基于长期监测的特重车流作用下桥梁动态放大系数研究［J］.振动工程学报, 2014(2): 68-78.
HAN Wanshui,YAN Junyuan,WU Jun, et al.Research on dynamic magnification factor of bridge under the action of extra heavy traffic flow based on long-term monitoring［J］.Journal of Vibration Engineering, 2014 (2): 68-78.

［19］陈洪彬, 谭平荣, 赵国虎.公路桥梁冲击系数适应性研究［J］.公路, 2014, 59(8): 259-262.
CHEN Hongbin,TAN Pingrong,ZHAO Guohu.Study on adaptability of impact coefficient of highway bridge［J］.Highway, 2014, 59(8): 259-262.

［20］袁向荣, 吴晶.极限荷载作用下简支梁桥冲击系数研究［J］.世界桥梁, 2014,42(1): 55-59.
YUAN Xiangrong,WU Jing.Study on impact coefficient of simply supported beam bridge under ultimate load［J］.World Bridges, 2014,42(1): 55-59.

［21］中华人民共和国交通运输部.公路桥梁荷载试验规程:JTG/T J21-01—2015［S］.北京：人民交通出版社，2015.

［22］韩万水, 王涛, 李永庆, 等.基于模型修正梁格法的车桥耦合振动分析系统［J］.中国公路学报, 2011,24(5): 47-55.
HAN Wanshui,WANG Tao,LI Yongqing, et al.Analysis system of vehicle-bridge coupling vibration with grillage method based on model updating［J］.China Joural of Highway and Transport, 2011,24(5): 47-55.

［23］公路桥梁(梁式桥)荷载试验技术规程:DB61/T 916—2014［S］.陕西省质量技术监督局，2014.

［24］周勇军,赵煜,贺拴海,等.刚构-连续组合桥梁冲击系数多因素灵敏度分析［J］.振动与冲击,2012,31(3):97-101.
ZHOU Yongjun,ZHAO Yu,HE Shuanhai, et al.Muti-parameters sensitivity analysis of impact factors for rigid-continuous combined bridge［J］.Journal of Vibration and Shock,2012,31(3):97-101.

［25］沈火明,肖新标.求解车桥耦合振动问题的一种数值方法［J］.西南交通大学学报,2003(6):658-662.
SHEN Huoming, XIAO Xinbiao.Numerical method for vehicle-bridge coupled vibrations［J］.Journal of Southwest Jiaotong University, 2003(6):658-662.