三相异步电动机驱动振动系统的Sommerfeld效应分析

PDF(1815 KB)

振动与冲击 ›› 2021, Vol. 40 ›› Issue (6) : 127-134.

论文

姜娇1，2，孔祥希1，罗园庆1，许琦1，陈长征1

作者信息 +

Sommerfeld effect in a vibration system driven by a three-phase asynchronous motor

JIANG Jiao1,2，KONG Xiangxi1，LUO Yuanqing1，XU Qi1，CHEN Changzheng1

Author information +

文章历史 +

摘要

提供有限动力的原动机称为非理想原动机。在工程中，几乎所有提供动力的原动机均为非理想原动机。由非理想原动机带动的振动系统称为非理想振动系统。在非理想振动系统中，原动机与振动系统的运动状态是相互作用、相互影响的。Sommerfeld效应是由于非理想原动机在振动系统共振区附近无法提供足够动力而产出的一种非线性跳跃现象。该试验研究了由一种典型原动机——三相异步电动机驱动振动系统的Sommerfeld效应。将三相异步电动机的动力学模型引入到振动系统中，建立了非理想振动系统的动力学模型。采用解析方法，建立了电机供电频率与转速之间的解析表达式，并应用摄动法进行了稳定性分析。基于Matlab/Simulink进行了仿真验证，说明了所采用解析方法的正确性。分析了偏心质量与电机功率对非理想振动系统的影响规律。通过研究发现，对于非理想振动系统的研究必须充分考虑原动机与振动系统的相互作用，忽略二者之间的相互作用是不合适的。

Abstract

The prime movers providing limit power are called non-ideal ones.In engineering, almost all the prime movers are non-ideal ones.The vibration systems driven by non-ideal prime movers are called non-ideal vibration systems.In non-ideal vibration systems, the motion states of the prime movers and the vibration systems interact with each other.Sommerfeld effect is a non-linear jumping phenomenon induced due to the fact that the non-ideal prime mover cannot provide enough power to pass the resonance region of the vibration system.The Sommerfeld effect in a vibration system driven by a typical prime mover, namely a three-phase asynchronous motor, was studied.Firstly, introducing the dynamic model of the three-phase asynchronous motor into the vibration system, a dynamic model of the non-ideal vibration system was established.Then, the analytical relation between the power supply frequency and the rotation speed of the motor was acquired by using the analytical method.Moreover, the stability analysis was carried out by using the perturbation method.Based on Matlab/Simulink, the simulation results show the correctness of the analytical method.Finally, the influences of the eccentric mass and motor power on the non-ideal vibration system were analyzed.It is found that the interaction between the prime mover and vibration system shouldn’t be ignored but must be fully considered in the study of non-ideal vibration systems.

导出引用

姜娇1，2，孔祥希1，罗园庆1，许琦1，陈长征1. 三相异步电动机驱动振动系统的Sommerfeld效应分析[J]. 振动与冲击, 2021, 40(6): 127-134

JIANG Jiao1,2，KONG Xiangxi1，LUO Yuanqing1，XU Qi1，CHEN Changzheng1. Sommerfeld effect in a vibration system driven by a three-phase asynchronous motor[J]. Journal of Vibration and Shock, 2021, 40(6): 127-134

参考文献

［1］BALTHAZARJ M, MOOK D T, WEBER H I, et al.An overview on non-ideal vibrations［J］.Meccanica, 2003, 38 (6):613-621.
［2］李强, 方一鸣, 李建雄, 等.伺服电机驱动的连铸结晶器振动系统受限状态下预设性能控制［J］.控制与决策, 2019, 34(3): 661-667.
LI Qiang, FANG Yiming, LI Jianxiong, et al.The prescribed performance control for the mold vibration displacement system driven by sever motor with constrained states［J］.Control and Decision, 2019, 34(3): 661-667.
［3］孙会来, 金纯, 张文明, 等.考虑驱动电机激振的电动车油气悬架系统振动分析［J］.农业工程学报, 2014, 30 (12):41-49.
SUN Huilai, JIN Chun, ZHANG Wenming, et al.Vibration analysis of hydro-pneumatic suspension system based on drive motor excitation force ［J］.Transactions of the Chinese Society of Agricultural Engineering, 2014, 30 (12):41-49.
［4］SAMANTARAY A K, DASGUPTA S S, BHATTACHARYYA R.Sommerfeld effect in rotationally symmetric planar dynamical systems ［J］.International Journal of Engineering Science, 2010, 48(1):21-36.
［5］BHARTI S K, BISOI A, SINHA A, et al.Sommerfeld effect at forward and backward critical speeds in a rigid rotor shaft system with anisotropic supports［J］.Journal of Sound and Vibration, 2019, 442:330-349.
［6］BISOI A, SAMANTARAY A K, BHATTACHARYYA R.Sommerfeld effect in a gyroscopic overhung rotor-disk system［J］.Nonlinear Dynamics, 2017, 88(3): 1565-1585.
［7］SINHA A, BHARTI S K, SAMANTARAY A K, et al.Sommerfeld effect in an oscillator with a reciprocating mass［J］.Nonlinear Dynamics, 2018, 93(3): 1719-1739.
［8］ROCHA R T, BALTHAZAR J M, TUSSET A M, et al.An analytical approximated solution and numerical simulations of a non-ideal system with saturation phenomenon［J］.Nonlinear Dynamics, 2018, 94(1):429-442.
［9］PALACIOS F J L, BALTHAZAR J M, ROCHA R T, et al.On vibration mitigation and energy harvesting of a non-ideal system with autoparametric vibration absorber system［J］.Meccanica, 2018, 53(13):3177-3188.
［10］JAIMEG C, JAVIER D.Non-linear vibrating systems excited by a nonideal energy source with a large slope characteristic［J］.Mechanical Systems and Signal Processing, 2017, 96:366-384.
［11］KOVRIGUINE D A.Synchronization and sommerfeld effect as typical resonant patterns［J］.Archive of Applied Mechanics, 2012, 82(5): 591-604.
［12］DJANAN A A N, NBENDJO B R N.Effect of two moving non-ideal sources on the dynamic of a rectangular plate［J］.Nonlinear Dynamics, 2018, 92 (2): 645-657.
［13］易园园，秦大同，刘长钊.冲击载荷下电机-多级齿轮系统动态特性研究［J］.振动与冲击, 2019, 38 (19):253-260.
YI Yuanyuan, QIN Datong, LIU Changzhao.Dynamic characteristics of a motor-driven multistage gear system under impact load ［J］.Journal of Vibration and Shock, 2019, 38 (19):253-260.
［14］张力豪，何立东，陈钊，等.整体式弹性环挤压油膜阻尼器结构设计与转子过临界实验研究［J］.振动与冲击, 2019, 38(18): 72-78.
ZHANG Lihao, HE Lidong, CHEN Zhao, et al.Structure design of an integral elastic ring squeeze film damper and experiments on the rotor passing through critical speed ［J］.Journal of Vibration and Shock, 2019, 38(18): 72-78.
［15］张微, 韩兵兵, 李响, 等.基于胞映射算法的转子-挤压油膜阻尼器系统多目标优化设计［J］.机械工程学报, 2019, 55 (19): 68-74.
ZHANG Wei, HAN Bingbing, LI Xiang, et al.Multi-objective optimization design of rotor-squeeze film damper system based on cell mapping method ［J］.Journal of Mechanical Engineering, 2019, 55 (19): 68-74.
［16］YAO H, CAO Y, DING Z, et al.Using grounded nonlinear energy sinks to suppress lateral vibration in rotor systems ［J］.Mechanical Systems and Signal Processing, 2019, 124:237-253.
［17］YAO H, WANG Y, CAO Y, et al.Multi-stable nonlinear energy sink for rotor system ［J］.International Journal of Non-Linear Mechanics, 2020, 118: 103273.
［18］陈坚.交流电机数学模型及调速系统［M］.北京: 国防工业出版社, 1989.