U形管内气液两相流诱导振动特性的实验研究

PDF(1994 KB)

振动与冲击 ›› 2023, Vol. 42 ›› Issue (14) : 76-83.

论文

马晓旭1,2，刘帅1，张政2，田茂诚2

作者信息 +

Experimental study on the gas-liquid two-phase flow-induced vibration in a U-tube

MA Xiaoxu1,2，LIU Shuai1，ZHANG Zheng2，TIAN Maocheng2

Author information +

文章历史 +

摘要

实验研究了横向U形管内气液两相流诱导振动的动态响应特性。重点研究了流型形式、气相表观流速Ug、液相表观流速Ul、体积含气率β等对振动响应强度arms的影响。结果表明，横向U形管振动主要表现为面内方向且为某一阶固有频率附近的低频振动，同时表现为拍振现象。U形弯头轴向不同测点振动频谱幅值呈现近似抛物线变化，在弯头90°处达到最大。arms由大到小依次为段塞-波形流、环状-波形流、环状-弥散流、塞状-泡状流和分层-塞状流。固定Ul时，arms随Ug的增加呈现先缓慢增长而后快速增大的趋势，快速增大的分界线约为Ug = 1 m/s；固定Ug时，arms随Ul的增加逐渐增大。较小β时，arms随β的增加呈现非常缓慢增长的趋势；当β增加到某节点时，振动强度快速增大，且快速增大的β节点值随液相表观流速Ul的增加而降低。

Abstract

The dynamic response characteristic of gas-liquid two-phase flow-induced vibration in a transverse U-shaped tube was studied experimentally. The effects of flow pattern, superficial gas velocity Ug, superficial gas velocity Ul, volume void fraction β on vibration response arms were studied. The results show that the vibration response in the transverse U-tube mainly presents the flapping phenomenon in plane direction at low frequency. The amplitude of the frequency spectrum presents the approximate parabola distribution along the axial measured points of the U-shaped elbow and reaches the maximum at the 90-degree position of the elbow. The order of the arms is slug-wavy flow, annular-wavy flow, annular dispersed flow, plug-bubble flow and plug-stratified flow. For a given Ug, the arms presents a trend of approximately flat growth and then a sharp increase with the increase of Ug. The boundary of the sharp increase is about Ug = 1m/s. For a given Ug, the arms increases with the rise of Ul. For a given β, arms presents a very slow growth trend with the increasing of β. However, when β increase to a certain value, arms increases greatly with the rise of β. The certain value decreases with the increasing of superficial liquid velocity.

导出引用

马晓旭1,2，刘帅1，张政2，田茂诚2. U形管内气液两相流诱导振动特性的实验研究[J]. 振动与冲击, 2023, 42(14): 76-83

MA Xiaoxu1,2，LIU Shuai1，ZHANG Zheng2，TIAN Maocheng2. Experimental study on the gas-liquid two-phase flow-induced vibration in a U-tube[J]. Journal of Vibration and Shock, 2023, 42(14): 76-83

参考文献

[1] CHU I C，CHUNG H J，LEE S. Flow-induced vibration of nuclear steam generator U-tubes in two-phase flow[J]. Nuclear Engineering and Design, 2011, 241: 1508-1515.
[2] PETTIGREW M J，TAYLOR C E. Two-phase flow-induced vibration: An overview[J]. Journal of Pressure Vessel Technology, 1994, 116: 233-253.
[3] PETTIGREW M J，TAYLOR C E，FISHER N J，et al. Flow-induced vibration: recent findings and open questions[J]. Nuclear Engineering and Design, 1998, 185: 249-276.
[4] 谭蔚，聂清德，段振亚. 横向流中两相流体诱发的振动[J]. 化工设备与管道，2005，42(5): 11-17.
TAN Wei，NIE Qingde，DUAN Zhenya. Vibration Induced by Two Phases Cross Flow[J]. Process Equipment and Piping, 2005, 42(5): 11-17.
[5] 郭海燕，傅强，娄敏. 海洋输液立管涡激振动响应及其疲劳寿命研究[J]. 工程力学，2005，22(4): 220-224.
GUO Haiyan，FU Qiang，LOU Min. Vortex-induced vibrations and fatigue life of marine risers conveying flowing fluid[J]. Engineering Mechanics, 2005, 22(4): 220-224.
[6] 陈伟民，张立武，李敏. 采用改进尾流振子模型的柔性海洋立管的涡激振动响应分析[J]. 工程力学，2010，27(5): 240-246.
CHEN Weimin，ZHANG Liwu，LI Min. Prediction of vortex-
induced vibration of flexible riser using improved wake-oscillator model[J]. Engineering Mechanics, 2010, 27(5): 240-246.
[7] 黄维平，刘娟，唐世振. 考虑流固耦合的大柔性圆柱体涡激振动非线性时域模型[J]. 振动与冲击，2012，31(9): 140-143.
HUANG Weiping，LIU Juan，TANG Shizhen. Nonlinear model of vortex induced vibration of flexible cylinder in consideration of fluid-structure interaction[J]. Journal of Vibration and Shock, 2012, 31(9): 140-143.
[8] 唐友刚，樊娟娟，张杰，等. 高雷诺数下圆柱顺流向和横向涡激振动分析[J]. 振动与冲击，2013，32(13): 88-92.
TANG Yougang，FAN Juanjuan，ZHANG Jie，et al. In line and transverse vortex-induced vibration analysis for a circular cylinder under high Reynolds number[J]. Journal of Vibration and Shock，2013，32(13): 88-92.
[9] 高云，任铁，付世晓，等. 柔性立管涡激振动响应特性试验研究[J]. 振动与冲击，2015，34(7): 6-11.
GAO Yun, REN Tie, FU Shixiao, et al. Tests for response characteristics of VIV of a flexible riser[J]. Journal of Vibration and Shock，2015，34(7): 6-11.
[10] 宋振华，段梦兰. 海洋立管横流向与双向涡激振动研究[J]. 石油机械，2016，44(7): 65-69.
SONG Zhenhua，DUAN Menglan. Study on the 1-DOF and 2-DOF VIV of Marine Riser[J]. China Petroleum Machinery, 2016, 44(7): 65-69.
[11] YIH T S，GRIFFITH P. Unstead momentum fluxes in two-phase flow and the vibration of nuclear system components[J]. Cambridge: Massachusetts Institute of Technology, 1968.
[12] TAY B L，THORPE R B. Effects of Liquid Physical Properties on the Forces Acting on a Pipe Bend in Gas–Liquid Slug Flow[J]. Chemical Engineering Research and Design, 2004, 82: 344-356.
[13] CARGNELOTTI M F，BELFORID S P C，SCHIFERLI W. Two-Phase Flow-Induced Forces on Bends in Small Scale Tubes[J]. Journal of Pressure Vessel Technology, 2010, 132: 041305(1-7).
[14] CARGNELUTTI M F，BELFORID S P C，SCHIFERLI W，et al. Multiphase Fluid Structure Interaction in Bends and T-Joints[C]. ASME 2010 Pressure Vessels and Piping Division/K-PVP Conference. Bellevue：ASME， 2010: 75-82.
[15] GIRAUDEAU M，MUREITHI N W，PETTIGREW M J. Two-Phase Flow-Induced Forces on Piping in Vertical Upward Flow: Excitation Mechanisms and Correlation Models[J]. Journal of Pressure Vessel Technology, 2013, 135: 030907.
[16] 宋军舰. 气液两相流管道振动检测研究[D]. 中国石油大学（华东），2011.
SONG Junjian. Research of Vibration Detection of Pipeline Conveying Gas-Liquid Two-Phase Flow[D]. China University of Petroleum (East China), 2011.
[17] 周云龙，常赫，赵盘. 起伏振动状态下水平管内气液两相流研究[J]. 振动与冲击，2019，38(20):1-6.
ZHOU Yunlong，CHANG He，ZHAO Pan. A study on gas-liquid two-phase flow in a horizontal tube under heaving motion[J]. Journal of Vibration and Shock, 2019, 38(20):1-6.
[18] 刘昶，李玉星，王琳，等. 海洋立管两相流动及管道振动特性试验研究[J]. 石油机械，2016，44(4): 46-50.
LIU Chang，LI Yuxing，WANG Lin，et al. Experimental Study on Two-phase Flow and Vibration Characteristics of Marine Riser[J]. China Petroleum Machinery, 2016, 44(4): 46-50.
[19] 王琳，李玉星，刘昶，等. 严重段塞流引起的海洋立管振动响应[J]. 工程力学，2017，34(6): 236-244.
WANG Lin，LI Yuxing，LIU Chang，et al. Dynamic Response of a Marine Riser Caused by Severe Slugging Flow[J]. Engineering Mechanics, 2017, 34(6): 236-244.
[20] MOFFAT R J. Describing the uncertainties in experimental results [J]. Experimental thermal and fluid science, 1988, 1: 3-17.
[21] MA X X，TIAN M C，ZHANG J Z，et al. Flow pattern identification for two-phase flow in a U-bend and its contiguous straight tubes[J]. Experimental thermal and fluid science, 2018, 93: 218-234.
[22] BLEVINS, ROBERT D. Flow-induced vibration[M]. USA, Krieger Publishing Company, 2006.