Investigation of paver screed on coupling compaction characteristics considering shock and vibration

PDF(1549 KB)

Journal of Vibration and Shock ›› 2018, Vol. 37 ›› Issue (16) : 91-97.

JIA Jie1，LIU Honghai1，XIN Qiang2，WAN Yipin1

Author information +

History +

Abstract

To improve the initial density of a paving mixture behind the paver, the research of the dynamic compaction system of materials and compaction equipment including tamper and vibrator is needed.In the system, the reaction force generated by the vibrating tamper will impact screed.A periodic rectangular wave for the impact was presented and a dynamic model of the compaction system under the action of shock and vibration excitation was established.The effects of different vibration frequency and vibration frequency on the dynamic mechanical properties of the screed were analyzed.At the same time, the coupling effect of vibration and the vibration were calculated.Then, based on the combination of the vibration theory and the mathematical model, frequency characteristic of the paving density was discussed.Test and simulation results show that, the maximum response peak of screed is at the resonance frequency, but the response peak above the resonant frequency section is reduced by 23% comparing with the maximum, obtaining higher paving density and smooth operation of screed.Further more, compaction effect of tamper is greater than the vibrator.There are three main frequency components acting on screed with the action of tamper and vibrator, these excitations can be adapted to the complex components with different natural frequencies, which may provide the possibility of multi resonance during paving compaction.Therefore, when studying the vibration performance of screed to paving mixture, not only to consider the main resonance of the vibration frequency close to the natural frequency of material, but also should pay attention to the impact of tamper and the coupling effect of them to compacting paving.Results of the experiment can provide the basis for the selection of vibration parameters of the paver screed.

Key words

paver / vibratory screed / shock and vibration / coupling compaction characteristics / best frequency ratio

Cite this article

EndNote

Ris (Procite)

Bibtex

Download Citations

JIA Jie1，LIU Honghai1，XIN Qiang2，WAN Yipin1. Investigation of paver screed on coupling compaction characteristics considering shock and vibration[J]. Journal of Vibration and Shock, 2018, 37(16): 91-97

References

[1] PLATI C, GEORGIOU P, LOIZOS A. Influence of different roller compaction modes on asphalt mix performance [J]. International Journal of Pavement Engineering, 2016, 17(1):1-7.
[2] 李淑明, 许志鸿. 沥青路面结构的耐久性分析[J]. 同济大学学报自然科学版, 2007, 35(4): 467-471.
LI Shu-ming, XU Zhi-hong. Durability analysis of asphalt pavement structures [J]. Jouranal of tongji unitversity (nature, science), 2007, 35(4): 467-471.
[3] WALAA S. MOGAWER, ALEXANDER J. AUSTERMAN, JO SIAS DANIEL, et al. Evaluation of the effects of hot mix asphalt density on mixture fatigue performance, rutting performance and MEPDG distress predictions [J]. International Journal of Pavement Engineering, 2011, 12(2):161-175.
[4] HOU H, WANG T, WU S, et al. Investigation on the pavement performance of asphalt mixture based on predicted dynamic modulus [J]. Construction & Building Materials, 2016, 106:11-17.
[5] 罗文军, 罗天洪, 甘信富. 多功能摊铺机振捣压实机构动力学仿真[J]. 重庆大学学报, 2012, 35(5):22-28.
LUO Wen-jun., LUO Tian-hong, GAN Xin-fu. Dynamics simulation of compacting mechanism for multi-function paver [J]. Journal of Chongqing University, 2012, 35(5), 22-28.
[6] 罗丹, 冯忠绪, 王晓云. 基于刚柔耦合的摊铺机熨平板横向振幅不均匀性研究[J]. 机械科学与技术, 2012, 31(8):1290-1294.
LUO Dan, FENG Zhong-xu, WANG Xiao-yun. Parameter optimization for compacting system of asphalt payer based on response surface method [J]. Journal of Vibration and Shock, 2012, 31(15): 92-95.
[7] Plati C, Georgiou P, Loizos A. Influence of different roller compaction modes on asphalt mix performance [J]. International Journal of Pavement Engineering, 2014, 17(1):64-70.
[8] 严世榕, 闻邦椿, 宫照民, 等. 沥青混凝土摊铺机熨平机构的动力学实验研究[J]. 福州大学学报(自然科学版), 1999, 27(5): 50-53.
YAN Shi-rong, WEN Bang-chun, GONG Zhao-min, et al. Dynamic experimental of compacting vibrators of an asphalt concrete road paver [J]. Journal of Fuzhou University (Natural Science), 1999, 27(5): 50-53.
[9] 田晋跃, 刘刚, 肖翀宇,等. 摊铺机压实装置的振动特性[J]. 中国工程机械学报, 2004, 2(2):201-205.
TIAN Jin-yue, LIU Gang, XIAO Zhong-yu, et al. Vibrating character of compacting mechanism of paver [J]. Chinese Journal of Construction Machinery, 2004, 2(2):201-205.
[10] 刘洪海, 贾洁, 马朝鲜, 张勇. 摊铺机熨平板对混合料振实特性的影响研究[J]. 中国公路学报, 2016, 29(7): 152-158.
LIU Hong-hai, JIA Jie, MA Chao-xian, et al. Investigation of paver screed on compaction characteristics of mixture [J]. China Journal of Highway and Transport, 2016, 29(7): 152-158.
[11] 冯忠绪, 朱林波, 王宪雪,等. 摊铺机振捣机构的动力学仿真与参数选择[J]. 中国工程机械学报, 2009, 7(1):26-30.
FENG Zhong-xu, ZHU Lin-bo, WANG Xian-xue, et al. Dynamic simulation and parametric selection for tamping mechanism of paving machines [J]. Chinese Journal of Construction Machinery, 2009, 7(1):26-30.
[12] 孙健. 摊铺机振捣器动力学特性分析[J]. 机械设计, 2015(12):83-86.
SUN Jian. Dynamic characteristics analysis of tamper mechanism for payer [J]. Journal of Machine Design, 2015(12):83-86.
[13] 闻邦椿, 刘树英, 张纯宇. 机械振动学.第2版[M]. 冶金工业出版社, 2011.
WEN Bang-chun, LIU Shu-ying, ZHNAG Chun-yu. Mechanical vibration. 2nd Edition [M]. Metallurgical Industry Press, 2011.
[14] 刘刚, 田晋跃, 肖翀宇,等. 摊铺机压实机构动态特性仿真[J]. 农业机械学报, 2005, 36(11):34-37.
LIU Gang, TIAN Jin-yue, XIAO Zhong-yu, et al. Simulation of Dynamic Character of Compacting Mechanism of Paver [J]. Transactions of the Chinese Society for Agricultural Machinery, 2005, 36(11):34-37.
[15] DEBELEAC C, NASTAC S. Stochastic approaches of nonlinear model-based simulations for vibratory compaction process [J]. Pamm, 2014, 14(1):749–750.
[16] 姚运仕, 肖刚, 董秀辉,等. 双频合成振动压实试验研究[J]. 中国公路学报, 2006, 19(1):122-126.
YAO Yun-shi, XIAO Gang, DONG Xiu-hui, et al. Experimental Study of Double-frequency Composed Vibrating Compaction [J]. China Journal of Highway and Transport, 2006,19(1):122-126.