Research on nonlinear floating slab track system design

PDF(7242 KB)

Journal of Vibration and Shock ›› 2023, Vol. 42 ›› Issue (11) : 170-182.

LIU Wei1,2, DU Xianggang1, XIAO Junheng3, YANG Jun2, ZHU Guangnan4,JIANG Cheng1, YANG Jizhong5, GUO Yousong6

Author information +

History +

Abstract

Aiming at the problems of the bad behavior of traditional steel floating slab track vibration isolation at lower frequencies and it’s larger vibration response, the designing optimized objective is proposed based on the load characteristics of the floating slab isolators. Based on the nonlinear damping vibration reduction technique and dynamic vibration absorbing technique, nonlinear floating slab track system and its key components (nonlinear damping isolators and dynamic vibration absorbers) are developed by means of theoretical analysis, numerical simulation and real scale track tests. This study shows that nonlinear damping, dynamic vibration absorbers and nonlinear floating slab system has a good vibration suppression effects on isolator supporting force, floating slab acceleration and tunnel vibration near the first nature frequency of the floating slab track, in which the nonlinear floating slab system has the most obvious vibration reduction effect, especially at lower frequencies. Besides, the nonlinear floating slab track system can suppress the vibration amplification problem when the dynamic vibration absorber deviates from its designing frequencies. The acceleration of dynamic vibration absorber is greater than that of the floating slab, while the displacement of them is nearly the same, which indicates that the dynamic vibration absorber can absort the vibration effectively, while it will not produce large relative displacement to ensure vehicle running safety.

Key words

Floating slab track / isolator loads characteristics / nonlinear damping / dynamic vibration absorber / nonlinear floating slab track system

Cite this article

EndNote

Ris (Procite)

Bibtex

Download Citations

LIU Wei1,2, DU Xianggang1, XIAO Junheng3, YANG Jun2, ZHU Guangnan4,JIANG Cheng1, YANG Jizhong5, GUO Yousong6. Research on nonlinear floating slab track system design[J]. Journal of Vibration and Shock, 2023, 42(11): 170-182

References

[1] Auersch, L. Realistic axle-load spectra from ground vibrations measured near railway lines[J]. International Journal of Rail Transportation, 3(4), 180–200.
[2] Villot, M., Augis, E., Guigou-Carter C., Jean, P., Ropars,
P., Bailhache, S. & Gallais, C. Vibration emission from railway lines in tunnel–characterization and prediction,International Journal of Rail Transportation, 4(4), 208– 228.
[3]Xia,H., Chen,J.G., Xia,C.Y., Inoue,H., Zenda, Y.&Qi,L. An experimental study of train induced structural and environmental vibrations of a rail transit elevated bridge with ladder tracks ,
Proceedings of the Institution of Mechanical Engineers , PartF:
Journal of Rail and Rapid Transit, 224(3), 115–24.
[4] Wolf,S. Potential low frequency ground vibration (<6.3Hz) impacts from underground LRT operations, Journal of Sound Vibration, 267(3),651-661.
[5] Li K F, Liu W N, Ding D Y, et al. Numerical analysis of low-frequency ground vibration induced by metro operations [C]// Environmental Vibrations: Prediction, Monitoring, Mitigation and Evaluation. Beijing, 2009:382-387.
[6]栗润德, 张鸿儒, 刘维宁. 地铁引起的地面振动及其对精密仪器的影响 [J]. 岩石力学与工程学报,2008,27(1):206-214.
Li Runde, Zhang Hongru, Liu Weining. Metro-induced Ground Vibrations and Their Impacts on Precision Instrument [J]. Chinese Journal of Rock Mechanics and Engineering, 2008,27(1):206-214.
[7] 丁德云. 地铁列车振动环境响应低频特征的分析与研究[D]. 北京交通大学，2010.
Ding Deyun. Study on Low Frequency Characteristics of Environmental Vibrations due to Metro Trains [D]. Beijing Jiaotong University, 2010.
[8] Saurenman,H. &Phillips,J. In-service tests of the effectiveness of vibration control measures on the BART rail transit system. Journal of Sound Vibration, 293(3-5), 888–900.
[9] Vogiatzis,K.E. &Kouroussis,G.. Prediction and efficient control of vibration mitigation using floating slabs: practical application at Athens metro lines 2 and 3, International Journal of Rail Transportation, 3(4), 215-232.
[10] Zhai,W., Xu,P. &Wang,K.W. Analysis of vibration reduction characteristics and applicability of steel spring floating-slab track. Journal of ModernTransportation, 19(4), 215-222.
[11] 刘卫丰, 刘维宁, 马蒙, 李克飞, 王文斌. 地铁列车运行引起的振动对精密仪器的影响研究[J]. 振动工程学报, 2012(02): 130-137.
Liu Weifeng, Liu Weining, Ma Meng, Li Kefei, Wang Wenbin. Study of effect on sensitive equipment due to vibrations induced
by metro traffic [J]. Journal of Vibration Engineering, 2012 (02): 130-137.
[12] 吴永芳. 轨道减振效果系统评价方法研究[J]. 中国铁道科学, 2013，(03): 1-6.
Wu Yongfang. Investigation into the Evaluation Method for Vibration Damping Effect of Track Systems [J]. China Railway Science, 2013，(03): 1-6.
[13] Hassan O A B. Train-induced groundborne vibration and noise in buildings [M]. Essex: Multi-Science Publishing Co. Ltd., 2006.
[14] 肖安鑫, 田野. 钢弹簧浮置板轨道对车内噪声影响的实测与分析[J]. 噪声与振动控制, 2012(1): 51-55.
Xiao Anxin, Tian Ye. Measurement and Analysis of Influence of Steel Spring Floating Slab Track on Vehicle Interior Noise [J]. Noise and Vibration Control, 2012(1): 51-55.
[15] 张生延. 浮置板与整体道床轨道车轨振动特性对比分析[J]. 铁道标准设计, 2016, 60(11): 10-13.
Zhang Shengyan. Vibration Analysis of Rail Vehicles on Floating Slab[J]. Railway Standard Design, 2016, 60(11): 10-13.
[16] 李伟. 地铁铜轨波磨成因及其对车辆/轨道行为的影响研究[D]. 西南交通大学，2015.
Li Wei. Study on Root Case of Metro Rail Corrugation and its Influence on Behavior of Vehicle-Track System. [D]. Xinan Jiaotong University, 2015.
[17]刘韦, 肖俊恒, 江成, 杨军, 杜香刚, 朱光楠, 施成, 刘吉烨. 基于SD振子理论的浮置板几何非线性隔振器研究[J]. 振动与冲击, 2021, 40(19): 286-293.
Liu Wei, Xiao Junheng, Jiang Cheng, Yang Jun, Du Xianggang, Zhu Guangnan, Shi Cheng, Liu Jiye. Floating Slab Geometrically Nonlinear Isolator Based on Oscillator Theory [J]. Journal of Vibration and Shock, 2021, 40(19): 286-293.
[18] 杜香刚. 基于隔振器荷载特征的非线性隔振器设计方法研究[J]. 振动与冲击, 2021,40(21):290-297.
Du Xianggang. Design Method of Nonlinear Vibration Isolator Based on Isolator Load Characteristics [J]. Journal of Vibration and Shock, 2021,40(21):290-297.
[19] 杜香刚,肖俊恒,杨吉忠,刘韦,朱光楠,李忠继,郭有松,丁炜等. 高稳定性低频减振轨道系统关键技术研究[R]. 北京：中国铁道科学研究院集团有限公司, 2020.
Du Xianggang, Xiao Junheng, Yang Jizhong, Liu Wei, Zhu Guangnan, Li Zhongji, Guo Yousong, Ding Wei etc. The Study of the Key Technology of High Stability and Low Frequency Vibration Reduction Track System [R]. Beijing: China Academy of Railway Sciences Corporation Limited, 2020.
[20] 杨吉忠, 颜华, 巍永幸, 郑小艳, 袁志刚, 蔡成标. 基于TRIZ理论的低频减振轨道结构研究[J]. 铁道工程学报, 2015,4: 60-64.
Yang Jizhong, Yan Hua, Wei Yongxing, Zheng Xiaoyan, Yuan Zhigang, Cai Chengbiao. Research on the Low Frequency Vibration Attenuation in Track Structure Based on TRIZ Theory [J]. Journal of Railway Engineering Society, 2015,4: 60-64.
[21] Shengyang Zhu, Jianwei Wang, Chengbiao Cai, Kaiyun Wang, Wanming Zhai. Development of a Vibration Attenuation Track at Low Frequencies for Urban Rail Transit [J]. Computer-Aided Civil and Infrastructure Engineering, 2017, 32: 713-726.
[22] 背户一登. 动力吸振器及其应用 [M]. 任明章译. 北京: 机械工业出版社, 2013: 22―83.
Seto K. Dynamic vibration absorber and its application [M]. Translated by Ren Mingzhang. Beijing: China Machine Press, 2013: 22―83. (in Chinese)